摘要
利用2kg级模拟工业高温焦化装置进行废轮胎与煤共焦化实验，考察了共焦化产物分布及产物收率受废轮胎橡胶变化的影响．结果表明，煤与废轮胎共焦化时存在“协同效应”，该效应具有明显的增气、增油和降低热解水的作用．当废轮胎配比为1％～7％时，焦炭收率随配比增加而降低，焦油收率呈增加趋势；与原煤单独炼焦相比，焦炭收率最多减少2．27%，焦油增加幅度至少是焦油总量的3．3％．用小颗粒度废轮胎可提高冶金焦率，当废轮胎颗粒度为D〈0．20mm时，冶金焦率增加幅度至少是原煤单独炼焦的3．6％．在废轮胎粒度D〈0．20mm，配比为3％时共焦化，可得到最大冶金焦率，并使焦油收率有所提高．
The product distribution and the effect on the yields from co-coking of coal with waste tire were investigated by using a 2 kg pyrolysis device for simulating the industrial coking procedure. The results indicate that there exists synergistic action during co-coking of coal with waste tire. This synergistic action has obvious impact on the increase of gas and oils, and decrease of water in the products yielded. In co-coking of coal with waste tire at the ratio of 1%- 7%, the yield of coke is decreased and the yield of tar is increased with the increase of waste tire added;the maximum of coke decrease is 2.27%, and the minimum of tar increase is 3.3% relative to original yield from coking of coal. When co-coking with smaller waste tire size, the yield of metallurgical coke is increased; with less than 0.20 mm of waste tire granule,at least 3.6% more metallurgical coke could be obtained. The maximum yield of metallurgical coke,and a little more yield of tar could be produced from co-coking of coal with waste tire at the ratio of 3% and less than 0.20 mm granule.
出处
《煤炭转化》
CAS
CSCD
北大核心
2006年第2期44-48,共5页
Coal Conversion
基金
北京市优秀人才培养专项基金资助项目(20041D0101104)
关键词
共焦化
废轮胎
炼焦配煤
产物收率
co-coking,waste tire, blended coal, products yield
