摘要
潜水电泵是量大面广的通用泵,对整机而言是可修复的。采用可维修的随机故障过程理论,通过大量的台架试验和现场试验,应用可靠性理论对试验数据进行统计分析,指出潜水电泵寿命分布的规律性,即潜水电泵在整个寿命期内,其故障分布函数为威布尔分布,在0～600 h期间,属于早期故障,600～3 200 h期间为偶然故障阶段,3 200 h以上为耗损故障期。潜水电泵经过充分磨合后,在偶然故障阶段,故障过程符合平稳的泊松过程,可用指数分布来描述其故障率。对于未经磨合的潜水电泵,其整个寿命期内的故障过程可用威布尔分布来描述。试验结果表明,提高潜水电泵寿命的关键是提高机械密封、保护器的质量水平。研究结果对潜水电泵的可靠性考核和可靠性设计具有重要的应用价值。
A lot of data obtained from laboratory test and spot test are analyzed, by applying the theory of the fault process in a maintainable system. The life distribution rules of the reliability data for submersible motor-pump have been presented and proved. The failure distribution of submersible motor-pumps accords with Weibull distribution in their whole life. The failures belong to early failures when the use time of submersible motor-pumps is less than 600 h. The failures remain with random failures when the use time is more than 600 h but is less than 3 200 h. And the failures belong to wear-out-failures when the use time is more than 3 200 h. If the submersible motor-pump is fully milled, the failure can be analyzed with exponential distribution, or it should be analyzed with Weibull distribution. The test results show that the primary measurements that quality of submersible motor-pump is improved are to improve the quality of mechanical seal sets and safeguards. At the same time, the search shows practical value in reliability assessment and reliability design.
出处
《机械工程学报》
EI
CAS
CSCD
北大核心
2007年第2期173-177,共5页
Journal of Mechanical Engineering
基金
2003年农业部行业标准制定资助项目(05285)
关键词
潜水电泵
试验
故障分布
Submersible motor-pump
Test
Failure distribution
