摘要
为探索脱水速度对无核白葡萄干制过程中膜脂过氧化作用及褐变的影响,以新疆无核白葡萄为试验材料,经过葡萄促干剂处理后,采用快速脱水和缓慢脱水2种处理,质量每减轻10%进行取样,测定脱水过程中果实干基含水率、干燥速率、褐变度、细胞膜透性、丙二醛(malonaldehyde,MDA)含量、脂氧合酶(lipoxygenase,LOX)、超氧化物歧化酶(superoxide dismutase,SOD)、过氧化氢酶(catalase,CAT)、过氧化物酶(peroxidase,POD)、多酚氧化酶(polyphenol oxidase,PPO)活性以及总酚含量的变化。结果表明:与缓慢脱水相比,快速脱水处理显著(P<0.05)降低了无核白葡萄褐变度的上升,减少MDA生成量以及膜透性的增加,抑制LOX活性的升高,保持较高的活性氧清除酶SOD、CAT及POD活性及较高的总酚含量,且使PPO活性保持在一个较低的水平。因此认为,快速脱水可以有效地抑制无核白葡萄的膜脂过氧化作用对细胞膜的破坏,保持细胞的完整性,且PPO活性较低,从而减少无核白葡萄脱水褐变的发生。研究结果为快速脱水在无核白葡萄干制中的应用提供参考。
Xinjiang is abundant in grapes. According to statistics, the production of grape accounted for 28.4%of the whole fruit production in Xinjiang in 2012. Since the mature period of grapes is very short, dehydrated drying after grape harvest is an important method of processing. Thompson seedless grape （Vitis vinifera L. var Wuhebai） is the main species of green raisins. As green raisins produced from traditional dry room are likely to browning, it’s well acknowledged as a key issue for the development of Xinjiang raisins. It was reported that the browning of actinidia arguta, longan, litchi and peach was caused by the polyphenol oxidase （PPO） contacting with the phenolic substrates, which resulted in the strengthen of the membrane lipid peroxidation and the increase of cell membrane permeability in fruits. These researches were focused on the relationship between browning caused by dehydration treatment before storage or nature water loss during storage and the membrane lipid peroxidation. But the dehydration was different from dehydration drying process. In order to investigate the mechanism that rapid dehydration inhibited the membrane lipid peroxidation, PPO, browning of Thompson seedless grapes during the drying, the changes of physiological and biochemical properties caused by grape browning in dehydration drying process were investigated in this study, and subsequently obtained the theoretical basis for preventing raisins browning and maintaining the quality of Thompson seedless grapes. Xinjiang Thompson seedless grapes were used as experiment materials. After being operated by the drying agent, two treatments, i.e. rapid dehydration and slow dehydration were conducted. Samples were taken every 10%loss in weight of the samples and stored for further use. The effects of different drying methods on dry basis moisture content, drying rate, browning, membrane permeability （relative conductivity）, malonaldehyde （MDA） content, lipoxygenase （LOX） activity, superoxide dismutase （SOD） activity, catalase （CAT） activity, peroxidase （POD） activity, polyphenol oxidase （PPO） activity and total phenol content were studied. The results showed that there were two stages in the drying of Thompson seedless grapes, i.e. constant rate drying and falling rate drying, and the significant browning of Thompson seedless grape during two drying methods both occured in the falling rate drying stage. The browning of Thompson seedless grape in the slow dehydration was in positive correlation with LOX activity, and the browning of Thompson Seedless grape in the rapid and slow dehydrations was in positive correlation with membrane permeability and MDA content, and negatively correlated to SOD activity, CAT activity, PPO activity, and total phenols content. It was found that the browning in the dehydration process of Thompson seedless grapes was closely related to the membrane lipid peroxidation. Rapid dehydration treatment significantly slowed down the development of the browning, as well as MDA content and membrane permeability; besides, LOX activity was also inhibited. The relatively high activity of active oxygen scavenging enzymes including SOD, CAT and POD and the more content of total phenols were maintained, and PPO was kept at a low level of activity. In conclusion, rapid dehydration can effectively inhibit the membrane lipid peroxidation of Thompson seedless grapes from cell membrane damage, maintain the integrity of the cells, and retard the browning of Thompson seedless grapes during drying and heating processes. The results provide a reference for the application of rapid dehydration in the drying of Thompson seedless grapes.
出处
《农业工程学报》
EI
CAS
CSCD
北大核心
2014年第17期285-294,共10页
Transactions of the Chinese Society of Agricultural Engineering
基金
国家自然科学基金(31201448)
新疆维吾尔自治区高校科研计划科学研究重点项目(XJEDU2012I16)
新疆农业大学大学生创新项目
关键词
水果
脱水
品质控制
脱水速度
无核白葡萄
膜脂过氧化
褐变
fruit
dehydration
quality control
dehydration speed
Thompson seedless grapes
membrane lipidsuper oxidization
browning
