摘要
研究了以丙烯酸 - 2 -乙基己酯 (2 -EHA)为交联敏化剂 ,γ辐照对羧基丁苯胶乳 (CS BRL)的交联行为 ,粒径大小、分布以及化学结构和热性能的影响 ,并推测了CSBRL辐射硫化的反应机理。结果表明 ,剂量率对CSBRL的交联行为影响不大 ;随着吸收剂量增大 ,交联密度急剧增大 ,体积溶胀度迅速减小 ,交联点间平均分子量减小。交联密度还随着敏化剂用量增加而增大。动态光散射仪的测试表明 ,吸收剂量 <2 5kGy时 ,胶乳的流体力学半径与辐照前相比变化不大 ,当吸收剂量增大到 10 2kGy时 ,流体力学半径与辐照前相比稍有增加。显微傅立叶红外光谱证实CS BRL不仅被辐射交联 ,还接枝上了丙烯酸酯。DSC分析表明 ,未加敏化剂的CSBRL玻璃化温度随剂量增加变化不大 ,而加入
The crosslinking behavior of carboxylated styrene-butadiene rubber latex (CSBRL) by using gamma radiation with 2-ethyl hexyl acrylate(2-EHA) as crosslinking sensitizer has been studied in detail. In addition, the variation of the particle size and distribution of latex, chemical structure and thermal property of CSBRL with absorbed dose have been discussed. Also the radiation vulcanization mechanism of CSBRL has been suggested. The experiments showed that, the dose rate has small effect on the cross-link behavior of CSBRL, and the swelling ratio decreased rapidly with the increase of absorbed dose. Increasing the dose, the average molecular weight per crosslinked units(Mc) decreased and crosslinking density increased. When the dose is below 25kGy, no significant changes in the particle size and distribution of latex were observed. The micro-FTIR analysis and DSC curves confirmed the existence of grafting reaction accompanying the crosslinking reaction during the gamma irradiation with 2-EHA as sensitizer.
出处
《辐射研究与辐射工艺学报》
CAS
CSCD
北大核心
2002年第3期171-177,共7页
Journal of Radiation Research and Radiation Processing
基金
国家重点基础研究专题经费 (G19990 6 4 80 0 )资助
关键词
Γ辐照
羟基丁苯橡胶乳液
交联
化学结构
热性能
rays irradiation, Carboxylated styrene-butadiene rubber latex, Crosslinking behavior, Chemical structure
