摘要
以十二烷基苯磺酸钠(SDBS)为表面活性剂配制微乳液对落地原油污染土壤进行应急处理及回收原油模拟实验。将原始与回收的原油、土壤进行对比发现:回收土壤的pH略高且大致呈中性,Zeta电位更小,黏粒体积分数减小,微乳液处理对土壤的理化性质影响较小;回收原油中饱和分含量升高,芳香分、胶质和沥青质含量降低,密度与黏度都降低,表明回收所得的是轻质原油。分析了SDBS、正丁醇、NaCl添加量及油水比对原油脱除率的影响,并对筛选出的3种配方微乳液进行温度、循环利用和放大实验检验原油脱除效果的稳定性,最终确定w(SDBS)=10%、w(n-butanol)=4.8%、w(NaCl)=0.8%、w(diesel)=12.8%的微乳液为处理落地原油的最优配方。
Sodium dodecyl benzene sulfonate (SDBS) was used as a surfactant to prepare microemulsion for emergency treatment of crude oil contaminated soil and recovery of crude oil. Comparison between the original and the recovered crude oil and soil samples was done. It is found that the pH of the recovered soil is slightly higher, the Zeta potential is smaller, the volume fraction of clay reduced, indicating that the microemulsion treatment has little influence on the physical and chemical properties of the soil. The recovered crude oil has higher saturation fraction, lower aromatic, resin and asphaltene content, lower density and viscosity, and belongs to light crude oil. The effects of SDBS, n-butanol and NaCl contents on de-oiling effect were investigated. Experiments on effects of oil/water ratio, temperature, recycling and scaling-up were carried out by using the selected three types of microemulsions formula. The optimal microemulsion formula for the de-oiling of crude oil contaminated soil is w(SDBS)=10%, w(n-butanol)=4.8%, w(NaCl)=0.8%, w(diesel)=12.8%.
作者
王龙
刘会娥
刘宇童
于云飞
陈爽
于文赫
张秀霞
WANG Long;LIU Huie;LIU Yutong;YU Yunfei;CHEN Shuang;YU Wenhe;ZHANG Xiuxia(State Key Laboratory of Heavy Oil Processing, China University of Petroleum, Qingdao 266580, Shandong, China;State Key Laboratory of Petroleum Pollution Control, Beijing 102206, China;CNPC Research Institute of Safety and Environmental Technology, Beijing 102206, China)
出处
《化工学报》
EI
CAS
CSCD
北大核心
2019年第7期2699-2707,共9页
CIESC Journal
基金
中国石油科技创新基金项目(2017D-5007-0601)
山东省自然科学基金项目(ZR2017MB015)
重质油国家重点实验室资助项目(SLKZZ-2017002)
关键词
石油
表面活性剂
微乳液
土壤
脱除率
petroleum
surfactants
microemulsion
soil
de-oiling rate
