摘要
研究超声时间、超声温度、50%柠檬酸添加量、加水量4个因素对超声波辅助浓香菜籽油水化脱胶效果的影响。在单因素试验基础上,利用响应面分析法对超声波辅助浓香菜籽油水化脱胶工艺进行优化。结果表明:超声波辅助浓香菜籽油水化脱胶的最优条件为超声时间15.5 min、超声温度45℃、50%柠檬酸添加量4%(以油质量计)、加水量4%(以油质量计),在此条件下脱胶后浓香菜籽油中磷脂含量为4.06 mg/100 g,脱磷率为92.11%,总酚含量为42.08 mg/100 g。在传统脱胶工艺条件下,即3%水(以油质量计),55℃下搅拌20 min后沉淀24 h,浓香菜籽油中磷脂含量为39.48 mg/100 g,脱磷率为23.31%,总酚含量为62.17 mg/100 g。经GC-MS分析,超声波辅助水化脱胶的浓香菜籽油中鉴定出27种主要的挥发性风味物质,其中主要呈味物质为硫甙降解产物。
The effects of ultrasonic time,ultrasonic temperature,50% citric acid dosage and water dosage on ultrasound-assisted hydration degumming of fragrant rapeseed oil were investigated. On the basis of single factor experiment,the ultrasound-assisted hydration degumming conditions of fragrant rapeseed oil were optimized by response surface methodology. The results showed that the optimal ultrasound-assisted hydration degumming conditions were determined as follows: ultrasonic time 15. 5 min,ultrasonic temperature 45 ℃,50% citric acid dosage 4%( based on the mass of oil),water dosage 4%( based on the mass of oil). Under these conditions,the phospholipid content of degummed oil was 4. 06 mg/100 g with the dephosphorization rate 92. 11%,and the total phenols content was 42. 08 mg/100 g. Under the traditional degumming process conditions of water dosage 3%( based on the mass of oil),degumming temperature 55 ℃, stirring time 20 min and precipitation time 24 h, the phospholipid content of degummed oil was 39. 48 mg/100 g with the dephosphorization rate 23. 31%,and the total phenols content was 62. 17 mg/100 g. GC-MS analysis showed that 27 volatile flavor compounds were identified in fragrant rapeseed oil obtained with ultrasound-assisted hydration degumming,and the main flavor components were degraded glucosinolate products.
作者
陈秋冰
熊双丽
李安林
何建琼
CHEN Qiubing;XIONG Shuangli;LI Anlin;HE Jianqiong(College of Life Science and Engineering,Southwest University of Science and Technology,Mianyang 621010,Sichuan,China;Sichuan Yukang Agricultural Science and Technology Limited Company,Deyang 618500,Sichuan,China)
出处
《中国油脂》
CAS
CSCD
北大核心
2021年第2期5-10,共6页
China Oils and Fats
基金
德阳市科技局项目(CKJ019)。
关键词
浓香菜籽油
超声波
水化脱胶
挥发性风味成分
fragrant rapeseed oil
ultrasound
hydration degumming
volatile flavor compound
