摘要
为实现移动机器人香蕉园巡检自动导航,研究提出了一种基于双目视觉的香蕉园巡检路径提取方法。首先由机器人搭载的双目相机获取机器人前方点云,进行预处理后对点云感兴趣区域进行二维投影并将投影结果网格化,得到网格地图;然后采用改进的K-means算法将道路两侧香蕉树分离,其中初始聚类中心通过对网格地图进行垂直、水平投影以及一、二阶高斯拟合确定;最后基于最小包围矩形提取导航路径,将道路两侧网格以最小矩形框包围,提取两包围框中间线作为期望导航路径。测试结果表明,改进的K-means算法聚类成功率为93%,较传统方法提高了12个百分点;导航路径提取平均横向偏差为14.27 cm,平均航向偏差为4.83°,研究方法可为香蕉园巡检机器人自动导航提供支持。
Banana is one of the most important fruits.A non-motorized vehicle can often be driven to inspect an orchard during the traditional planting management.However,the labor-intensive and time-consuming mode cannot fully meet the large-scale production in modern agriculture.Alternatively,it is very necessary to develop inspection robots with automatic navigation for banana orchards,particularly on the detection of navigation paths in a complex field.In this study,a navigation path detection was proposed to realize the automatic inspection in a banana orchard using binocular vision of mobile robots.The inspection robot also consisted of a binocular camera,a main control unit,and a robot chassis.The specific procedure was as follows.1)The binocular images were acquired to reconstruct in three dimensions using the ZED camera mounted on the mobile robot.Then,the point cloud was preprocessed,including the coordinate system conversion and space limit.After that,the point cloud was segmented by double thresholds.Specifically,the height of the point cloud was obtained for the banana trees,where the heights of ground points were mainly distributed below 0.5 m,and those of leaves were above 1.5 m.Therefore,the height range of 0.5~1.5 m was selected as the region of interest(ROI)of the point cloud in the navigation path detection.2)The ROI region was projected onto a two-dimensional plane.The projection of the point cloud was also gridded to reduce the amount of calculation.A traditional K-means clustering was improved,according to the grid’s distribution of banana trees.The initial centers of the cluster were also determined to improve the clustering effect using the vertical and horizontal projection of the grid map,together with the first and the second order Gaussian fitting.Specifically,the grid map was first projected vertically,thereby to be fitted using the second-order Gaussian curve.Among them,the X-axis for the two maximum points of the fitted curve was taken as the X-axis for the two initial centers of the cluster.The grid map was then divided into two areas on the left and right by the center line of two X-axes.After that,a horizontal projection was performed on the two regions,further to be fitted by the first-order Gaussian curve.The maximum points of two curves were selected as the coordinates of the initial cluster centers on the left and right areas.A calculated position was utilized as the initial clustering center.The grids of banana trees on both sides of the road were also divided into two clusters using the K-means clustering.Correspondingly,the clusters were surrounded by the smallest rectangular boxes.The middle line of the two boxes was detected as the navigation path.3)The path detection was tested in the banana orchards.The robot was manually controlled to perform the inspection operations on the motorized and non-motorized lanes in the banana garden,while the point cloud images in the front were acquired simultaneously.The point cloud images were used to test the path detection.The results showed that the clustering success rate of the improved K-means clustering was 93%,compared with the traditional one of 81%.The positions on the edge of banana trees near the road were also labeled manually.The least square method was then utilized to fit the positions for the road boundary line.The center line of the left and right boundary lines was taken as the desired navigation path.The 93 clustered images were tested successfully by the improved K-means.Consequently,the path extraction demonstrated that the average distance deviation of the navigation path within 2 m was 14.27 cm,and the average angle deviation was 4.83°,compared with the manually labeled path.The findings can provide strong support to the automatic navigation of inspection robots in a banana orchard.
作者
张振乾
李世超
李晨阳
曹如月
张漫
李寒
李修华
Zhang Zhenqian;Li Shichao;Li Chenyang;Cao Ruyue;Zhang Man;Li Han;Li Xiuhua(Key Laboratory of Modern Precision Agriculture System Integration Research,Ministry of Education,China Agricultural University,Beijing 100083,China;Key Laboratory of Agricultural Information Acquisition Technology,Ministry of Agriculture and Rural Affairs,China Agricultural University,Beijing 100083,China;School of Electrical Engineering,Guangxi University,Nanning 530004,China)
出处
《农业工程学报》
EI
CAS
CSCD
北大核心
2021年第21期9-15,共7页
Transactions of the Chinese Society of Agricultural Engineering
基金
广西创新驱动发展专项资金(桂科AA18118037)
国家重点研发计划(2019YFB1312305)
中国农业大学建设世界一流大学(学科)
特色发展引导专项资金(2021AC006)。
关键词
机器人
机器视觉
香蕉园
巡检
路径提取
robots
machine vision
banana orchard
inspection
path extraction
