The Bacillus firmus was immobilized into Ca-alginate beads according to the different initial biomass concentration, calcification time and activation time. Three types of immobilized Bacillus firmus beads were packed...The Bacillus firmus was immobilized into Ca-alginate beads according to the different initial biomass concentration, calcification time and activation time. Three types of immobilized Bacillus firmus beads were packed respectively in trickling biofilter to purify xylene contained waste gases, and the performance of immobilized-cell biofilter was compared with traditional biofilm attached biofilter packed with two types of ceramic pellets. The results showed that three types of immobilized beads had different capabilities for removing xylene and life-spans. Higher initial biomass in immobilized beads resulted in better performance but shorter life-span. Activation process can remarkably enhance the activity of bacteria, and the removal efficiency of xylene can substantially be improved. Calcification time had influence on life-span of immobilized beads. Without acclimation, the cell-entrapped biofilter can obtain the maximum elimination capacity of 92.4 g/（m^3·h）. However, compared with biofilm attached biofilter, it has a poorer intrinsic drawback in volatile organic compounds （VOCs） removal due to the existence of excess mass transfer resistance.展开更多
[Objective] To find out the process conditions and influence factors for the biotreatment of odor gases of hydrogen sulfide（H2S） and ammonia（NH3）. [Method]The degradation performances on H2 S and NH3 were investig...[Objective] To find out the process conditions and influence factors for the biotreatment of odor gases of hydrogen sulfide（H2S） and ammonia（NH3）. [Method]The degradation performances on H2 S and NH3 were investigated during the start-up and stable operation process of biofilter with ceramsites as the packing microorganisms. [Result] The biofilm formation of the biofilter system to purify the waste gas of H2 S was completed within 9 d, and the removal rate of H2 S could reach up to 99% with the initial concentration of 100-1 000 mg/m^3 and empty bed residence time（EBRT） of142-290 s. The biofilm formation of the biofilter system to purify the waste gas of NH3 was completed within 10 d with the removal rate reaching up to 94.61%.[Conclusion] Under suitable conditions, the biofilter showed high removal rates to both H2 S and NH3.展开更多
A field-scale aged refuse （AR） biofilter constructed in Shanghai Refuse Landfill, containing about 7000 m^3 aged refuse inside, was evaluated for its performance in the treatment of landfill leachate. This AR biofil...A field-scale aged refuse （AR） biofilter constructed in Shanghai Refuse Landfill, containing about 7000 m^3 aged refuse inside, was evaluated for its performance in the treatment of landfill leachate. This AR biofilter can be divided into three stages and can manage 50 m^3 landfill leachate per day. The physical, chemical, and biological characteristics of AR were analyzed for evaluating the AR biofilter as leachate treatment host. The results revealed that over 87.8%-96.2% of COD and 96.9%-99.4% of ammonia nitrogen were removed by the three-stage AR biofilter when the infiuent leachate COD and ammonia nitrogen concentration were in the range 5478-10842 mg/L and 811-1582 mg/L, respectively. The final effluent was inodorous and pale yellow with COD and ammonia nitrogen below 267-1020 mg/L and 6-45 mg/L, respectively. The three-stage AR biofilter had efficient nitrification but relative poor denitrification capacity with a total nitrogen （TN） removal of 58%-73%. The external temperature of AR biofilter did not influence the total ammonia nitrogen removal significantly. It was concluded that the scale-up AR biofilter can work very well and can be a promising technology for the treatment of landfill leachate.展开更多
Volatile organic compounds(VOC's) in air have become major concern in recent years. Biodegradation of a mixture of ethanol and methanol vapor was evaluated in a laboratory biofilter with a bed of compost and polys...Volatile organic compounds(VOC's) in air have become major concern in recent years. Biodegradation of a mixture of ethanol and methanol vapor was evaluated in a laboratory biofilter with a bed of compost and polystyrene particles using an acclimated mixed culture. The continuous performance of the biofilter was studied with different proportion of ethanol and methanol at different initial concentration and flow rates. The result showed significant removal for both ethanol and methanol, which were composition dependent. The presence of either compound in the mixture inhibited the biodegradation of the other.展开更多
The biofilter is cost-effective for the waste gases treatment. The bacterial is the main microorganism in the conventional biofilters. However, it faces some problems on the elimination of hydrophobic compounds. In or...The biofilter is cost-effective for the waste gases treatment. The bacterial is the main microorganism in the conventional biofilters. However, it faces some problems on the elimination of hydrophobic compounds. In order to overcome these problems, the biofilters with fungi were developed. The objective of this study is to investigate the factors affecting ethyl mercaptan(EM)-degradation using a fungal biofilter. A laboratory experiment was set up. The effects of loading rate, empty bed residence times(EBRT) and pH on EM degradation were investigated. Over 95% removals of EM could be achieved, under the condition of the influent loadings below 50 g/(m·h). Removal efficiencies improved to 98% with EM loading decreased to 45 g/(m·h). For long EBRT of 58 s corresponding to a flow rate of 0.3 m3/h, the EM removal efficiencies of over 98% were observed. However, when EBRT was decreased to 14 s, the removal efficiencies fell under 80%. The pH range of 3—5 was feasible to fungi.展开更多
Carbon foam—a kind of new engineering material as packing material was adopted in three biofilters with different pore dimensions and adapted autotrophic nitrite nitrobacteria to investigate the purification of nitri...Carbon foam—a kind of new engineering material as packing material was adopted in three biofilters with different pore dimensions and adapted autotrophic nitrite nitrobacteria to investigate the purification of nitric oxide (NO) in a gas stream. The biofilm was developed on the surface of carbon foams using nitrite as its only nitric source. The moisture in the filter was maintained by ultrasonic aerosol equipment which can minimize the thickness of the liquid film. The liquid phase nitrification test was conducted to determine the variability and the potential of performance among the three carbon foam biofilters. The investigation showed that during the NO2^-—N inlet concentration of 200 g·L^-1·min^-1 to 800 g·L^-1·min^-1, the 24PPC (pores per centimeter) carbon foam biofilter had the greatest potential, achieving the NO2^-—N removal efficiency of 94% to 98%. The 8PPC and 18PPC carbon foam biofilters achieved the NO2^-—N removal efficiency of 15% to 21% and of 30% to 40%, respectively. The potential for this system to remove NO from a gas stream was shown on the basis of a steady removal efficiency of 41% to 50% which was attained for the 24PPC carbon foam biofilter at specified NO inlet concentration of 66.97 mg·m^-3 to 267.86mg·m^-3 and an empty-bed residence time of 3.5 min.展开更多
Uneven distribution of volatile organic compounds （VOCs） and biomass, and excess biomass accumulation in some biofilters hinder the application of biofiltration technology. An innovative multilayer rotating drum bio...Uneven distribution of volatile organic compounds （VOCs） and biomass, and excess biomass accumulation in some biofilters hinder the application of biofiltration technology. An innovative multilayer rotating drum biofilter （RDB） was developed to correct these problems. The RDB was operated at an empty bed contact time （EBCT） of 30 s and a rotational rate of 1.0 r/min. Diethyl ether was chosen as the model VOC. Performance of the RDB was evaluated at organic loading rates of 32,1, 64.2, 128, and 256 g ether/（m^3·h） （16.06 g ether/（m^3·h） ≈ 1.0 kg chemical oxygen demand （COD）/（m^3·d））. The EBCT and organic loading rates were recorded on the basis of the medium volume. Results show that the ether removal efficiency decreased with an increased VOC loading rate. Ether removal efficiencies exceeding 99% were achieved without biomass control even at a high VOC loading rate of 128 g ether/（m^3·h）. However, when the VOC loading rate was increased to 256 g ether/（m^3·h）, the average removal efficiency dropped to 43%. Nutrient limitation possibly contributed to the drop in ether removal efficiency. High biomass accumulation rate was also observed in the medium at the two higher ether loading rates, and removal of the excess biomass in the media was necessary to maintain stable performance. This work showed that the RDB is effective in the removal of diethyl ether from waste gas streams even at high organic loading rates. The results might help establish criteria for designing and operating RDBs.展开更多
The potential of using denitrifying and nitrifying concurrent biofilters for the removal of nitrogen oxides from synthetic gas streams was studied under the condition of high oxygen concentration. It was found that ...The potential of using denitrifying and nitrifying concurrent biofilters for the removal of nitrogen oxides from synthetic gas streams was studied under the condition of high oxygen concentration. It was found that more than 85% of nitric oxide was removed from synthetic combustion gas-streams which contained 20% oxygen and 350 μL/L NO, with a residence time of 60 seconds. In the process, it was found that the existing of oxygen showed no evident negative effect on the efficiency of nitrogen removal.展开更多
Volatile organic compounds (VOCs) are a new class of air pollutants posing threat to the environment. Newer technologies are being developed for their control among which biofiltration seem to be most attractive. Biof...Volatile organic compounds (VOCs) are a new class of air pollutants posing threat to the environment. Newer technologies are being developed for their control among which biofiltration seem to be most attractive. Biofiltration of methanol vapor from air stream was evaluated in this study. Experimental investigations were conducted on a laboratory scale biofilter, containing mixture of compost and polystyrene inert particles as the filter materials. Mixed consortium of activated sludge was used as an inoculum. The continuous performance of biofilter for methanol removal was monitored for different concentrations and flow rates. The removal efficiencies decreased at higher concentrations and higher gas flow rates. A maximum elimination capacity of 85 g/(m 3·h) was achieved. The response of biofilter to upset loading operation showed that the biofilm in the biofilters was quite stable and quickly adapted to adverse operational conditions.展开更多
A laboratory-scale trickling biofilter column, filled with Raschig rings and inoculated with Pseudomonas putida （ATCC 1785） was used to ＇purify chlorobenzene contained waste gases. Sodium dodecyl sulfonate （SDS） ...A laboratory-scale trickling biofilter column, filled with Raschig rings and inoculated with Pseudomonas putida （ATCC 1785） was used to ＇purify chlorobenzene contained waste gases. Sodium dodecyl sulfonate （SDS） was used to enhance the performance of trickling biofilter. Purification performance of the trickling biofilter was examined for chiorobenzene inlet concentration of 1.20,-5.04 g/m^3 at different EBRTs between 76N153 s. Without SDS addition, with simultaneous increase in chlorobenzene inlet loading rate and gas flow rate, 100% removal efficiency was achieved at EBRT of 109 s and inlet loadings below 5120 mg/m^3. Addition of SDS to nutrient solution led to improvement of trickling biofilter purification performance. By introducing 25 mg/L SDS, the removal efficiency was increased by 21% and elimination capacity up to 234 g/（m^3.h） was achieved at chlorobenzene inlet loading of 241 g/（m^3.h）. Although SDS concentration experienced a low rate reduction after continuous nutrient solution recirculation, this result has period little influence on trickling biofilter＇s removal efficiency in monitoring period.展开更多
Liquid manure storage may contribute to methane （CH4） emission and this emission can be greatly reduced if appropriate management practices are applied. Biofiltration has been used in other fields for mitigating gre...Liquid manure storage may contribute to methane （CH4） emission and this emission can be greatly reduced if appropriate management practices are applied. Biofiltration has been used in other fields for mitigating greenhouse gas （GHG） emission （e.g., landfill） and shown promise for mitigation OH4 emis- sion from liquid manure storage. It has been reported that biofilter was capable of reducing 80% of CH4 emissions from manure storage. The OH4 removal efficiency is influenced by many factors, including OH4 and 02 concentrations, temperature, moisture, composition of the filter bed, nutrient, and empty bed resi- dency time （EBRT）. Biological conversion of methane of a biofilter is a slow process due to the low water solubility of methane. The residence times （EBRT） between 5 min and 5 h have been used, whereas a typical EBRT of 25 s is used for common biofilter applications. Temperature at which methanotrophic bac- teria are active ranges from 10℃ to 45℃. The maximum activity is found at around 30℃. The optimal filter bed water content depends on both the gas flow rate and the type of filter bed （soil, compost, etc.） and ranges from 30%-70% of the water holding capacity. Compost is the best material for filter bed. The optimal pH for methanotrophic bacteria is neutral to slightly acidic. Copper and nitrogen compounds especially nitrate are important nutrients to methanotrophic bacteria but their optimal concentrations have not been founded. Phosphorus and other elements such as potassium and manganese are reported to affect the performance of methanotrophic bacteria but need further confirmation.展开更多
Volatile organic compounds(VOCs) are typical pollutants that affect air quality.Discharge plasma is thought to be a potential method that can remove VOCs from flue gas.In this experiment,pulsed corona discharge plasma...Volatile organic compounds(VOCs) are typical pollutants that affect air quality.Discharge plasma is thought to be a potential method that can remove VOCs from flue gas.In this experiment,pulsed corona discharge plasma combined with a biological tower was carried out to remove the benzene series,and toluene was selected as the typical VOC.The results indicated that the removal efficiency of toluene by pulsed corona plasma was slightly higher than that of direct current(DC) corona plasma,while its energy efficiency was much higher than DC corona plasma.Under the optimal experimental conditions of pulse voltage 8.5 kV,initial toluene concentration 1400 mg m^(-3),and toluene flow rate of 121h^(-1),the toluene removal efficiency reached 77.11% by the single method of pulsed corona discharge plasma,and the energy efficiency was up to 1.515 g/(kW·h) under the pulse voltage of 4.0 kV.The trickling biofilter was constructed by using the screened and domesticated Acinetobacter baumannii,and the highest toluene removal efficiency by the pulsed corona discharge plasma combined with the trickling biofilter rose up to 97.84%.Part of the toluene was degraded into CO_(2),H_(2)O,and some intermediate products such as o-diphenol under the influence of Acinetobacter baumannii.When the remaining waste gas passed through the discharge plasma reactor,the benzene ring structure could be directly destroyed by the collision between toluene and plasma.Meanwhile,O·,OH·,and some other oxidizing radicals generated by the discharge also join into the oxidative decomposition of toluene and its intermediate products,thereby further improving the removal efficiency of toluene.Therefore,the two-stage plasma-biofilter system not only showed a high toluene removal efficiency,but also had a good energy efficiency.The results of this study will provide theoretical support and technical reference for industrial VOC treatment.展开更多
Bacteria play a major role in metabolizing ammonia and other metabolites in recirculating aquaculture systems(RASs).To characterize and compare the bacterial communities in the biofilters of two full-scale RASs for th...Bacteria play a major role in metabolizing ammonia and other metabolites in recirculating aquaculture systems(RASs).To characterize and compare the bacterial communities in the biofilters of two full-scale RASs for the culture of puffer fish,Takifugu rubripes,at different ages and densities were studied.In overall,47807 optimized reads of the 16 S rRNA gene with V4-V5 region were obtained from four biofilm samples collected after biofilm maturation.At 97%cut-off level,these sequences were clustered into 500 operational taxonomic units,and were classified into 19 bacterial phyla and 138 genera.At the phylum level,Proteobacteria and Bacteroidetes were the most abundant,followed by Nitrospirae and Planctomycetes.At the genus level,Colwellia,Marinifilum,Oceanospirillum,Lutibacter,Winogradskyella,Pseudoalteromonas,Arcobacter,and Phaeobacter were the top members.Nitrosomonas and Nitrospira were main ammonia-and nitrite-oxidizing bacteria.Differences in bacterial communities at different sampling dates and similarities of both biofilters were revealed in the Venn diagram and cluster analysis.Maintaining a good water quality and health offarmed fish in RASs depended on the correct management of the bacterial communities.This study provides more accurate information on the bacterial communities associated with the bifilters of both RASs.展开更多
Biofiltration is emerging as a promising cost effective technique for the Volatile Organic Compounds (VOCs) removal from industrial waste gases. In the present investigation a comparative modeling study has been carri...Biofiltration is emerging as a promising cost effective technique for the Volatile Organic Compounds (VOCs) removal from industrial waste gases. In the present investigation a comparative modeling study has been carried out using Radial Basis Function Neural Network (RBFN) and Response Surface Methodology (RSM) to predict and optimize the performance of a biofilter system treating toluene (a model VOC). Experimental biofilter system performance data collected over a time period by daily measurement of inlet VOC concentration, retention time, pH, temperature and packing moisture content was used to develop the mathematical model. These independent variables acted as the inputs to the mathematical model developed using RSM and RBFN, while the VOC removal efficiency was the biofilter system performance parameter to be predicted. The data set was divided into two parts: 60% of data was used for training phase and remaining 40% of data was used for the testing phase. The average % error for RSM and RBFN were 7.76% and 3.03%, and R2 value obtained were 0.8826 and 0.9755 respectively. The results indicated the superiority of RBFN in the prediction capability due to its ability to approximate higher degree of nonlinearity between the input and output variables. The optimization of biofilter parameters was also done using RSM to optimize the biofilter performance. RSM being structured in nature enabled the study of interaction effect between the independent variables on biofilter performance.展开更多
Biomass and microbial activity in backwashing processes of a biofilter for tertiary treatment were investigated. The microbial groups revealed new distribution along the biofilter depth after low flow rate backwashing...Biomass and microbial activity in backwashing processes of a biofilter for tertiary treatment were investigated. The microbial groups revealed new distribution along the biofilter depth after low flow rate backwashing for a short time. Then the start-up process was accelerated by backwashing. The biomass profile and microbial activity profile both varying with depth before and after backwashing, can be mathematically described by quadratic equations. Using the profiles, the difference of oxygen demand can be calculated to determine the airflow rate during backwashing. Combined with the difference between biofilters and rapid gravity filters, analysis of biomass and microbial activity can determine more accurately the required airflow rate during backwashing.展开更多
Several strategies with different combination of inocula and packing material were investigated to obtain the optimal start-up time and elimination capacity (EC) in toluene biofiltration. The inocula contained the act...Several strategies with different combination of inocula and packing material were investigated to obtain the optimal start-up time and elimination capacity (EC) in toluene biofiltration. The inocula contained the activated sludge and toluene degrading bacteria, and the packing material consisted of different mixing ratios of peat and wood chips. A final toluene load of 21.2 g/(m3·h) was attained step by step in four parallel biofilters. A shortest start-up time of 15 days and a highest EC of 17.0 g/(m3·h) were observed in the biofilter B-4, which was inoculated with a special microbial consortium consisting of three strains of toluene degrading bacteria and was packed with the mixture of peat and wood chips at a ratio of 80:20 (w/w). These results indicated that inoculating pre-acclimatized microbes dramatically shortened the start-up time, and such a composition of packing material could maintain an appropriate environment (with the bed porosity and water content equating to 0.45 and 1.96, respectively) for the growth of dominant toluene degrading bacteria in the biofilter.展开更多
Pseudomonas sp. ZD8 isolated from contaminated soil was immobilized with platane wood chips to produce packing materials for a novel biofilter system utilized to control restaurant emissions. The effects of operationa...Pseudomonas sp. ZD8 isolated from contaminated soil was immobilized with platane wood chips to produce packing materials for a novel biofilter system utilized to control restaurant emissions. The effects of operational parameters including retention time, temperature, and inlet gas concentration on the removal efficiency and elimination capacity were evaluated. Cri- teria necessary for a scale-up design of the biofilter was established. High and satisfactory level of rapeseed oil smoke removal efficiency was maintained during operation and the optimal retention time was found to be 18 s corresponding to smoke removal efficiency greater than 97%. The optimal inlet rapeseed oil smoke loading was 120 mg/(m3?h) at the upper end of the linear cor- relation between inlet loading and elimination capacity.展开更多
A new biofilter technology was used to control the methane concentration in the coal mine. The results indicate that the biofilter achieves a steady methane removal capacity of 1 470 mg/（Loh） after 30 days start-up....A new biofilter technology was used to control the methane concentration in the coal mine. The results indicate that the biofilter achieves a steady methane removal capacity of 1 470 mg/（Loh） after 30 days start-up. More than 90% of the methane can be removed with an empty bed retention time （EBRT） of 5.6 min when the inlet concentration of methane （IMC） is lower than 70 mg/L （10%, V/V） and about 80% when IMC is at 105 mg/L （15%, V/V）. The biofilter is still a reliable method to control methane concentration as an auxiliary means to boost coal mine production safety together with aggrandized ventilation and drainage technologies, even though the removal efficiency of methane is not very satisfactory with a high IMC （〉10%） or a short EBRT （〈3.8 min）.展开更多
Developing new techniques to remove and recover phosphorous simultaneously from wastewaters is very important for sustainable utilization of phosphorous resource and prevention of eutrophication. The feasibility of ph...Developing new techniques to remove and recover phosphorous simultaneously from wastewaters is very important for sustainable utilization of phosphorous resource and prevention of eutrophication. The feasibility of phosphorus bioaccumulation in a novel continuous alternating anaerobic /aerobic biofilter and benefits of such accumulation for its further recovery as magnesium ammonia phosphate (MAP) were studied. The system was operated for seven months and employed the atomic absorption spectrophotometer (AAS) method to analyze the distribution change of magnesium and calcium with phosphate in the biofilter during that period. The benefits of utilizing the biofilter system to accumulate phosphorous & magnesium and suppress calcium simultaneously to phosphorous recovery as MAP were explained with the aid of chemical equilibrium models. The improved phosphorus recovery from 42% to 82% was approved in the recovery experiments and the recovery products mainly as MAP were evidenced and characterized with scanning electron microscopy (SEM) . The study provides references for designing and operating the novel alternating anaerobic /aerobic biofilter for phosphorus bioaccumulation and recovery.展开更多
基金Project supported by the National Nature Science Foundation of China （Grant No.50608049）, and the Shanghai Leading Aca- demic Disciplines （Grant No.T105）, and the Youth Development Foundation of Shanghai Municipal Commission of Education （Grant No.04AC107）
文摘The Bacillus firmus was immobilized into Ca-alginate beads according to the different initial biomass concentration, calcification time and activation time. Three types of immobilized Bacillus firmus beads were packed respectively in trickling biofilter to purify xylene contained waste gases, and the performance of immobilized-cell biofilter was compared with traditional biofilm attached biofilter packed with two types of ceramic pellets. The results showed that three types of immobilized beads had different capabilities for removing xylene and life-spans. Higher initial biomass in immobilized beads resulted in better performance but shorter life-span. Activation process can remarkably enhance the activity of bacteria, and the removal efficiency of xylene can substantially be improved. Calcification time had influence on life-span of immobilized beads. Without acclimation, the cell-entrapped biofilter can obtain the maximum elimination capacity of 92.4 g/（m^3·h）. However, compared with biofilm attached biofilter, it has a poorer intrinsic drawback in volatile organic compounds （VOCs） removal due to the existence of excess mass transfer resistance.
基金Supported by the Climbing Program for Graduates of Guangdong Province~~
文摘[Objective] To find out the process conditions and influence factors for the biotreatment of odor gases of hydrogen sulfide（H2S） and ammonia（NH3）. [Method]The degradation performances on H2 S and NH3 were investigated during the start-up and stable operation process of biofilter with ceramsites as the packing microorganisms. [Result] The biofilm formation of the biofilter system to purify the waste gas of H2 S was completed within 9 d, and the removal rate of H2 S could reach up to 99% with the initial concentration of 100-1 000 mg/m^3 and empty bed residence time（EBRT） of142-290 s. The biofilm formation of the biofilter system to purify the waste gas of NH3 was completed within 10 d with the removal rate reaching up to 94.61%.[Conclusion] Under suitable conditions, the biofilter showed high removal rates to both H2 S and NH3.
基金supported by the Ministry of Education of China (No. 305005)the Science and Technology Commission of Shanghai Municipality (No. 05DZ12003).
文摘A field-scale aged refuse （AR） biofilter constructed in Shanghai Refuse Landfill, containing about 7000 m^3 aged refuse inside, was evaluated for its performance in the treatment of landfill leachate. This AR biofilter can be divided into three stages and can manage 50 m^3 landfill leachate per day. The physical, chemical, and biological characteristics of AR were analyzed for evaluating the AR biofilter as leachate treatment host. The results revealed that over 87.8%-96.2% of COD and 96.9%-99.4% of ammonia nitrogen were removed by the three-stage AR biofilter when the infiuent leachate COD and ammonia nitrogen concentration were in the range 5478-10842 mg/L and 811-1582 mg/L, respectively. The final effluent was inodorous and pale yellow with COD and ammonia nitrogen below 267-1020 mg/L and 6-45 mg/L, respectively. The three-stage AR biofilter had efficient nitrification but relative poor denitrification capacity with a total nitrogen （TN） removal of 58%-73%. The external temperature of AR biofilter did not influence the total ammonia nitrogen removal significantly. It was concluded that the scale-up AR biofilter can work very well and can be a promising technology for the treatment of landfill leachate.
文摘Volatile organic compounds(VOC's) in air have become major concern in recent years. Biodegradation of a mixture of ethanol and methanol vapor was evaluated in a laboratory biofilter with a bed of compost and polystyrene particles using an acclimated mixed culture. The continuous performance of the biofilter was studied with different proportion of ethanol and methanol at different initial concentration and flow rates. The result showed significant removal for both ethanol and methanol, which were composition dependent. The presence of either compound in the mixture inhibited the biodegradation of the other.
文摘The biofilter is cost-effective for the waste gases treatment. The bacterial is the main microorganism in the conventional biofilters. However, it faces some problems on the elimination of hydrophobic compounds. In order to overcome these problems, the biofilters with fungi were developed. The objective of this study is to investigate the factors affecting ethyl mercaptan(EM)-degradation using a fungal biofilter. A laboratory experiment was set up. The effects of loading rate, empty bed residence times(EBRT) and pH on EM degradation were investigated. Over 95% removals of EM could be achieved, under the condition of the influent loadings below 50 g/(m·h). Removal efficiencies improved to 98% with EM loading decreased to 45 g/(m·h). For long EBRT of 58 s corresponding to a flow rate of 0.3 m3/h, the EM removal efficiencies of over 98% were observed. However, when EBRT was decreased to 14 s, the removal efficiencies fell under 80%. The pH range of 3—5 was feasible to fungi.
基金Supported by the National Natural Science Foundation of China (No. 20276070)the National 863 Project of China (No. 2002AA649310) the Natural Science Foundation of Zhejiang Province (No. 202084).
文摘Carbon foam—a kind of new engineering material as packing material was adopted in three biofilters with different pore dimensions and adapted autotrophic nitrite nitrobacteria to investigate the purification of nitric oxide (NO) in a gas stream. The biofilm was developed on the surface of carbon foams using nitrite as its only nitric source. The moisture in the filter was maintained by ultrasonic aerosol equipment which can minimize the thickness of the liquid film. The liquid phase nitrification test was conducted to determine the variability and the potential of performance among the three carbon foam biofilters. The investigation showed that during the NO2^-—N inlet concentration of 200 g·L^-1·min^-1 to 800 g·L^-1·min^-1, the 24PPC (pores per centimeter) carbon foam biofilter had the greatest potential, achieving the NO2^-—N removal efficiency of 94% to 98%. The 8PPC and 18PPC carbon foam biofilters achieved the NO2^-—N removal efficiency of 15% to 21% and of 30% to 40%, respectively. The potential for this system to remove NO from a gas stream was shown on the basis of a steady removal efficiency of 41% to 50% which was attained for the 24PPC carbon foam biofilter at specified NO inlet concentration of 66.97 mg·m^-3 to 267.86mg·m^-3 and an empty-bed residence time of 3.5 min.
基金partially supported by the National Natural Science Foundation of China(No.50778066)the Program for New Century Excellent Talents in University from the Ministry of Education of China(No.NCET-05-0701)the University of Cincinnati.
文摘Uneven distribution of volatile organic compounds （VOCs） and biomass, and excess biomass accumulation in some biofilters hinder the application of biofiltration technology. An innovative multilayer rotating drum biofilter （RDB） was developed to correct these problems. The RDB was operated at an empty bed contact time （EBCT） of 30 s and a rotational rate of 1.0 r/min. Diethyl ether was chosen as the model VOC. Performance of the RDB was evaluated at organic loading rates of 32,1, 64.2, 128, and 256 g ether/（m^3·h） （16.06 g ether/（m^3·h） ≈ 1.0 kg chemical oxygen demand （COD）/（m^3·d））. The EBCT and organic loading rates were recorded on the basis of the medium volume. Results show that the ether removal efficiency decreased with an increased VOC loading rate. Ether removal efficiencies exceeding 99% were achieved without biomass control even at a high VOC loading rate of 128 g ether/（m^3·h）. However, when the VOC loading rate was increased to 256 g ether/（m^3·h）, the average removal efficiency dropped to 43%. Nutrient limitation possibly contributed to the drop in ether removal efficiency. High biomass accumulation rate was also observed in the medium at the two higher ether loading rates, and removal of the excess biomass in the media was necessary to maintain stable performance. This work showed that the RDB is effective in the removal of diethyl ether from waste gas streams even at high organic loading rates. The results might help establish criteria for designing and operating RDBs.
基金supported by the National Natural Science Foundation of China(Grants No.20277009)
文摘The potential of using denitrifying and nitrifying concurrent biofilters for the removal of nitrogen oxides from synthetic gas streams was studied under the condition of high oxygen concentration. It was found that more than 85% of nitric oxide was removed from synthetic combustion gas-streams which contained 20% oxygen and 350 μL/L NO, with a residence time of 60 seconds. In the process, it was found that the existing of oxygen showed no evident negative effect on the efficiency of nitrogen removal.
文摘Volatile organic compounds (VOCs) are a new class of air pollutants posing threat to the environment. Newer technologies are being developed for their control among which biofiltration seem to be most attractive. Biofiltration of methanol vapor from air stream was evaluated in this study. Experimental investigations were conducted on a laboratory scale biofilter, containing mixture of compost and polystyrene inert particles as the filter materials. Mixed consortium of activated sludge was used as an inoculum. The continuous performance of biofilter for methanol removal was monitored for different concentrations and flow rates. The removal efficiencies decreased at higher concentrations and higher gas flow rates. A maximum elimination capacity of 85 g/(m 3·h) was achieved. The response of biofilter to upset loading operation showed that the biofilm in the biofilters was quite stable and quickly adapted to adverse operational conditions.
基金Project supported by the National Natural Science Foundation of China(Grant No.50608049)the Shanghai Leading Academic Discipline Project(Grant No.T105) the Youth Development Foundation of Shanghai Municipal Commission of Education(Grant No.04AC107)
文摘A laboratory-scale trickling biofilter column, filled with Raschig rings and inoculated with Pseudomonas putida （ATCC 1785） was used to ＇purify chlorobenzene contained waste gases. Sodium dodecyl sulfonate （SDS） was used to enhance the performance of trickling biofilter. Purification performance of the trickling biofilter was examined for chiorobenzene inlet concentration of 1.20,-5.04 g/m^3 at different EBRTs between 76N153 s. Without SDS addition, with simultaneous increase in chlorobenzene inlet loading rate and gas flow rate, 100% removal efficiency was achieved at EBRT of 109 s and inlet loadings below 5120 mg/m^3. Addition of SDS to nutrient solution led to improvement of trickling biofilter purification performance. By introducing 25 mg/L SDS, the removal efficiency was increased by 21% and elimination capacity up to 234 g/（m^3.h） was achieved at chlorobenzene inlet loading of 241 g/（m^3.h）. Although SDS concentration experienced a low rate reduction after continuous nutrient solution recirculation, this result has period little influence on trickling biofilter＇s removal efficiency in monitoring period.
文摘Liquid manure storage may contribute to methane （CH4） emission and this emission can be greatly reduced if appropriate management practices are applied. Biofiltration has been used in other fields for mitigating greenhouse gas （GHG） emission （e.g., landfill） and shown promise for mitigation OH4 emis- sion from liquid manure storage. It has been reported that biofilter was capable of reducing 80% of CH4 emissions from manure storage. The OH4 removal efficiency is influenced by many factors, including OH4 and 02 concentrations, temperature, moisture, composition of the filter bed, nutrient, and empty bed resi- dency time （EBRT）. Biological conversion of methane of a biofilter is a slow process due to the low water solubility of methane. The residence times （EBRT） between 5 min and 5 h have been used, whereas a typical EBRT of 25 s is used for common biofilter applications. Temperature at which methanotrophic bac- teria are active ranges from 10℃ to 45℃. The maximum activity is found at around 30℃. The optimal filter bed water content depends on both the gas flow rate and the type of filter bed （soil, compost, etc.） and ranges from 30%-70% of the water holding capacity. Compost is the best material for filter bed. The optimal pH for methanotrophic bacteria is neutral to slightly acidic. Copper and nitrogen compounds especially nitrate are important nutrients to methanotrophic bacteria but their optimal concentrations have not been founded. Phosphorus and other elements such as potassium and manganese are reported to affect the performance of methanotrophic bacteria but need further confirmation.
基金financially supported by the National Key Research and Development Program of China(No.2019YFC0214303)the Applied Basic Research Program of Wuhan,China(No.2015060101010068)
文摘Volatile organic compounds(VOCs) are typical pollutants that affect air quality.Discharge plasma is thought to be a potential method that can remove VOCs from flue gas.In this experiment,pulsed corona discharge plasma combined with a biological tower was carried out to remove the benzene series,and toluene was selected as the typical VOC.The results indicated that the removal efficiency of toluene by pulsed corona plasma was slightly higher than that of direct current(DC) corona plasma,while its energy efficiency was much higher than DC corona plasma.Under the optimal experimental conditions of pulse voltage 8.5 kV,initial toluene concentration 1400 mg m^(-3),and toluene flow rate of 121h^(-1),the toluene removal efficiency reached 77.11% by the single method of pulsed corona discharge plasma,and the energy efficiency was up to 1.515 g/(kW·h) under the pulse voltage of 4.0 kV.The trickling biofilter was constructed by using the screened and domesticated Acinetobacter baumannii,and the highest toluene removal efficiency by the pulsed corona discharge plasma combined with the trickling biofilter rose up to 97.84%.Part of the toluene was degraded into CO_(2),H_(2)O,and some intermediate products such as o-diphenol under the influence of Acinetobacter baumannii.When the remaining waste gas passed through the discharge plasma reactor,the benzene ring structure could be directly destroyed by the collision between toluene and plasma.Meanwhile,O·,OH·,and some other oxidizing radicals generated by the discharge also join into the oxidative decomposition of toluene and its intermediate products,thereby further improving the removal efficiency of toluene.Therefore,the two-stage plasma-biofilter system not only showed a high toluene removal efficiency,but also had a good energy efficiency.The results of this study will provide theoretical support and technical reference for industrial VOC treatment.
基金Supported by the National Key R&D Program of China(No.2017YFD0701700)National Natural Science Foundation of China(Nos.31472312,31672673)。
文摘Bacteria play a major role in metabolizing ammonia and other metabolites in recirculating aquaculture systems(RASs).To characterize and compare the bacterial communities in the biofilters of two full-scale RASs for the culture of puffer fish,Takifugu rubripes,at different ages and densities were studied.In overall,47807 optimized reads of the 16 S rRNA gene with V4-V5 region were obtained from four biofilm samples collected after biofilm maturation.At 97%cut-off level,these sequences were clustered into 500 operational taxonomic units,and were classified into 19 bacterial phyla and 138 genera.At the phylum level,Proteobacteria and Bacteroidetes were the most abundant,followed by Nitrospirae and Planctomycetes.At the genus level,Colwellia,Marinifilum,Oceanospirillum,Lutibacter,Winogradskyella,Pseudoalteromonas,Arcobacter,and Phaeobacter were the top members.Nitrosomonas and Nitrospira were main ammonia-and nitrite-oxidizing bacteria.Differences in bacterial communities at different sampling dates and similarities of both biofilters were revealed in the Venn diagram and cluster analysis.Maintaining a good water quality and health offarmed fish in RASs depended on the correct management of the bacterial communities.This study provides more accurate information on the bacterial communities associated with the bifilters of both RASs.
文摘Biofiltration is emerging as a promising cost effective technique for the Volatile Organic Compounds (VOCs) removal from industrial waste gases. In the present investigation a comparative modeling study has been carried out using Radial Basis Function Neural Network (RBFN) and Response Surface Methodology (RSM) to predict and optimize the performance of a biofilter system treating toluene (a model VOC). Experimental biofilter system performance data collected over a time period by daily measurement of inlet VOC concentration, retention time, pH, temperature and packing moisture content was used to develop the mathematical model. These independent variables acted as the inputs to the mathematical model developed using RSM and RBFN, while the VOC removal efficiency was the biofilter system performance parameter to be predicted. The data set was divided into two parts: 60% of data was used for training phase and remaining 40% of data was used for the testing phase. The average % error for RSM and RBFN were 7.76% and 3.03%, and R2 value obtained were 0.8826 and 0.9755 respectively. The results indicated the superiority of RBFN in the prediction capability due to its ability to approximate higher degree of nonlinearity between the input and output variables. The optimization of biofilter parameters was also done using RSM to optimize the biofilter performance. RSM being structured in nature enabled the study of interaction effect between the independent variables on biofilter performance.
基金Project (No. 2002BA806B04) supported by the National Techno-logical Research Program of China
文摘Biomass and microbial activity in backwashing processes of a biofilter for tertiary treatment were investigated. The microbial groups revealed new distribution along the biofilter depth after low flow rate backwashing for a short time. Then the start-up process was accelerated by backwashing. The biomass profile and microbial activity profile both varying with depth before and after backwashing, can be mathematically described by quadratic equations. Using the profiles, the difference of oxygen demand can be calculated to determine the airflow rate during backwashing. Combined with the difference between biofilters and rapid gravity filters, analysis of biomass and microbial activity can determine more accurately the required airflow rate during backwashing.
基金financial supports by the National Natural Science Foundation of China (Grant No. 21505156)the Fundamental Research Funds for the Central Universities (24720122043)the Scientific Research and Technological Development Projects of PetroChina Co., Ltd. (2013F-2101)
文摘Several strategies with different combination of inocula and packing material were investigated to obtain the optimal start-up time and elimination capacity (EC) in toluene biofiltration. The inocula contained the activated sludge and toluene degrading bacteria, and the packing material consisted of different mixing ratios of peat and wood chips. A final toluene load of 21.2 g/(m3·h) was attained step by step in four parallel biofilters. A shortest start-up time of 15 days and a highest EC of 17.0 g/(m3·h) were observed in the biofilter B-4, which was inoculated with a special microbial consortium consisting of three strains of toluene degrading bacteria and was packed with the mixture of peat and wood chips at a ratio of 80:20 (w/w). These results indicated that inoculating pre-acclimatized microbes dramatically shortened the start-up time, and such a composition of packing material could maintain an appropriate environment (with the bed porosity and water content equating to 0.45 and 1.96, respectively) for the growth of dominant toluene degrading bacteria in the biofilter.
基金Project (No. 2003C23019) supported by the Major Scientific and Technological Project of Zhejiang Province China
文摘Pseudomonas sp. ZD8 isolated from contaminated soil was immobilized with platane wood chips to produce packing materials for a novel biofilter system utilized to control restaurant emissions. The effects of operational parameters including retention time, temperature, and inlet gas concentration on the removal efficiency and elimination capacity were evaluated. Cri- teria necessary for a scale-up design of the biofilter was established. High and satisfactory level of rapeseed oil smoke removal efficiency was maintained during operation and the optimal retention time was found to be 18 s corresponding to smoke removal efficiency greater than 97%. The optimal inlet rapeseed oil smoke loading was 120 mg/(m3?h) at the upper end of the linear cor- relation between inlet loading and elimination capacity.
文摘A new biofilter technology was used to control the methane concentration in the coal mine. The results indicate that the biofilter achieves a steady methane removal capacity of 1 470 mg/（Loh） after 30 days start-up. More than 90% of the methane can be removed with an empty bed retention time （EBRT） of 5.6 min when the inlet concentration of methane （IMC） is lower than 70 mg/L （10%, V/V） and about 80% when IMC is at 105 mg/L （15%, V/V）. The biofilter is still a reliable method to control methane concentration as an auxiliary means to boost coal mine production safety together with aggrandized ventilation and drainage technologies, even though the removal efficiency of methane is not very satisfactory with a high IMC （〉10%） or a short EBRT （〈3.8 min）.
基金Scientific Research Foundation for Returned Overseas Chinese Scholars of China(No.SEM-11W11329)National Natural Science Foundation for Young Scholars of China(No.20906011)+1 种基金Natural Science Foundation of Shanghai,China(No.102R1401200)The Fundamental Research Funds for the Central Universities(Donghua University)of China(No.11D11308)
文摘Developing new techniques to remove and recover phosphorous simultaneously from wastewaters is very important for sustainable utilization of phosphorous resource and prevention of eutrophication. The feasibility of phosphorus bioaccumulation in a novel continuous alternating anaerobic /aerobic biofilter and benefits of such accumulation for its further recovery as magnesium ammonia phosphate (MAP) were studied. The system was operated for seven months and employed the atomic absorption spectrophotometer (AAS) method to analyze the distribution change of magnesium and calcium with phosphate in the biofilter during that period. The benefits of utilizing the biofilter system to accumulate phosphorous & magnesium and suppress calcium simultaneously to phosphorous recovery as MAP were explained with the aid of chemical equilibrium models. The improved phosphorus recovery from 42% to 82% was approved in the recovery experiments and the recovery products mainly as MAP were evidenced and characterized with scanning electron microscopy (SEM) . The study provides references for designing and operating the novel alternating anaerobic /aerobic biofilter for phosphorus bioaccumulation and recovery.
