Petroleum coke was thermally treated on a fixed bed reactor in a temperature range of 1173-1673 K. The changes of the elemental composition and crystalline structure of petroleum coke, with heat treatments as well as ...Petroleum coke was thermally treated on a fixed bed reactor in a temperature range of 1173-1673 K. The changes of the elemental composition and crystalline structure of petroleum coke, with heat treatments as well as the gasification reactivity of the heat-treated petroleum cokes were investigated. The results showed that the petroleum coke was carbonized and grapbitized to a higher degree with increasing heating temperature, while the gasification reactivity decreased. The treatment at temperatures of 1173 and 1473 K significantly enlarged the specific surface area and the pore volume of petroleum coke. Both the specific surface area and the pore volume decreased at 1673 K. An empirical normal distribution function model （NDFM） was found to fit the gasification rates of petroleum coke well. The correlation coefficient of petroleum coke by normal distribution function model at different heat treatment temperatures is between 0.93 and 0.95.展开更多
Siderite,as an abundant iron ore,has not been effectively utilized,with a low utilization rate.In this study,the in-situ kinetics and mechanism of siderite during suspension magnetization roasting(SMR)were investigate...Siderite,as an abundant iron ore,has not been effectively utilized,with a low utilization rate.In this study,the in-situ kinetics and mechanism of siderite during suspension magnetization roasting(SMR)were investigated to improve the selective conversion of siderite to magnetite and CO,enriching the theoretical system of green SMR using siderite as a reductant.According to the gas products analyses,the peak value of the reaction rate increased with increasing temperature,and its curves presented the feature of an early peak and long tail.The mechanism function of the siderite pyrolysis was the contraction sphere model(R_(3)):f(α)=3(1−α)2/3;E_(α)was 46.4653 kJ/mol;A was 0.5938 s^(−1);the kinetics equation was k=0.5938exp[−46.4653/(RT)].The in-situ HT-XRD results indicated that siderite was converted into magnetite and wüstite that exhibited a good crystallinity in SMR under a N_(2) atmosphere.At 620℃,the saturation magnetization(M_(s)),remanence magnetization(Mr),and coercivity(Hc)of the product peaked at 53.63×10^(-3)A·m^(2)/g,10.23×10^(-3)A·m^(2)/g,and 12.40×10^(3)A/m,respectively.Meanwhile,the initial particles with a smooth surface were transformed into particles with a porous and loose structure in the roasting process,which would contribute to reducing the grinding cost.展开更多
Waterborne acrylic emulsions modified with organic siloxanes and aziridine crosslinker were synthesized and applied as coating of controlled release fertilizer. The free films were characterized and the nutrient relea...Waterborne acrylic emulsions modified with organic siloxanes and aziridine crosslinker were synthesized and applied as coating of controlled release fertilizer. The free films were characterized and the nutrient release profiles of the coated fertilizers were determined. The results show that methyl silicone oil and methylsilanolate sodium could not improve water resistance performance and glass transition temperature Tgof coatings, while the firmness is enhanced. Aziridine crosslinker improves the water resistance performance, firmness and Tg. Incorporation of methyl silicone oil and aziridine crosslinker gives an excellent aqueous acrylic emulsion for coated controlled release fertilizer, with the 30-day cumulative nutrient release reduced to 16% and an estimated nutrient release duration over 190 days. Therefore, this waterborne coating is promising to meet the requirements for controlled release of nutrient and environmental protection.展开更多
The universal creep equation is successful in relating the creep （ε） to the aging time （t） , coefficient of retardation time （β） , and intrinsic time （ to ）. This relation was used to treat the creep experim...The universal creep equation is successful in relating the creep （ε） to the aging time （t） , coefficient of retardation time （β） , and intrinsic time （ to ）. This relation was used to treat the creep experimental data for polyvinyl chloride （ PVC ） specimens at a given stress and different aging times. The βgs found by the “polynomial fitting” method in this work instead of the “middle - point” method reported in the literature. The unified master line was constructed with the treated data and curves according to the universal equation. The master line can be used to predict the long- term creed behavior and lifetime by extrapolating.展开更多
文摘采用控制酯化率和不外加相转移催化剂、在敞开体系中自催化磺化反应的方法,合成了4种不同乙氧基加成数 n(n=3,5,7,9。下同)的阴离子表面活性剂月桂醇聚氧乙烯醚(LEO_n)己基琥珀酸混合双酯磺酸钠(LHSS_n)。对由4种 LEO_n 来分别合成 LHSS_n 的最佳工艺条件与 LEO_n 的乙氧基加成数的关系进行了研究。结果表明:随着乙氧基加成数的增加,单酯化反应的酯化率达到约100%时的反应温度从90℃增加到140℃;双酯化率达到约95%时的反应温度从140℃增加到170℃,己醇过量从100%增加到400%。同样地随着乙氧基加成数的增加,磺化剂亚硫酸氢钠过量从5%增加到10%,反应时间从2.25 h 增加到2.75 h,反应温度从130℃增加到180℃。从酯化反应中 LEO 进攻羰基 C 的空间位阻对酯化反应的影响以及磺化反应中产物自催化作用对磺化反应的影响分别解释了反应性变化的原因。
文摘Petroleum coke was thermally treated on a fixed bed reactor in a temperature range of 1173-1673 K. The changes of the elemental composition and crystalline structure of petroleum coke, with heat treatments as well as the gasification reactivity of the heat-treated petroleum cokes were investigated. The results showed that the petroleum coke was carbonized and grapbitized to a higher degree with increasing heating temperature, while the gasification reactivity decreased. The treatment at temperatures of 1173 and 1473 K significantly enlarged the specific surface area and the pore volume of petroleum coke. Both the specific surface area and the pore volume decreased at 1673 K. An empirical normal distribution function model （NDFM） was found to fit the gasification rates of petroleum coke well. The correlation coefficient of petroleum coke by normal distribution function model at different heat treatment temperatures is between 0.93 and 0.95.
基金Projects(51874071,52022019,51734005)supported by the National Natural Science Foundation of ChinaProject(161045)supported by the Fok Ying Tung Education Foundation for Yong Teachers in the Higher Education Institutions of China。
文摘Siderite,as an abundant iron ore,has not been effectively utilized,with a low utilization rate.In this study,the in-situ kinetics and mechanism of siderite during suspension magnetization roasting(SMR)were investigated to improve the selective conversion of siderite to magnetite and CO,enriching the theoretical system of green SMR using siderite as a reductant.According to the gas products analyses,the peak value of the reaction rate increased with increasing temperature,and its curves presented the feature of an early peak and long tail.The mechanism function of the siderite pyrolysis was the contraction sphere model(R_(3)):f(α)=3(1−α)2/3;E_(α)was 46.4653 kJ/mol;A was 0.5938 s^(−1);the kinetics equation was k=0.5938exp[−46.4653/(RT)].The in-situ HT-XRD results indicated that siderite was converted into magnetite and wüstite that exhibited a good crystallinity in SMR under a N_(2) atmosphere.At 620℃,the saturation magnetization(M_(s)),remanence magnetization(Mr),and coercivity(Hc)of the product peaked at 53.63×10^(-3)A·m^(2)/g,10.23×10^(-3)A·m^(2)/g,and 12.40×10^(3)A/m,respectively.Meanwhile,the initial particles with a smooth surface were transformed into particles with a porous and loose structure in the roasting process,which would contribute to reducing the grinding cost.
基金Supported by the National 12th Five-Year Science and Technology Supporting Program(2011BAD11B01)the Research & Development Projects Cooperation Project of Chinese Academy of Sciences(YDJDBNJ-2012-023)
文摘Waterborne acrylic emulsions modified with organic siloxanes and aziridine crosslinker were synthesized and applied as coating of controlled release fertilizer. The free films were characterized and the nutrient release profiles of the coated fertilizers were determined. The results show that methyl silicone oil and methylsilanolate sodium could not improve water resistance performance and glass transition temperature Tgof coatings, while the firmness is enhanced. Aziridine crosslinker improves the water resistance performance, firmness and Tg. Incorporation of methyl silicone oil and aziridine crosslinker gives an excellent aqueous acrylic emulsion for coated controlled release fertilizer, with the 30-day cumulative nutrient release reduced to 16% and an estimated nutrient release duration over 190 days. Therefore, this waterborne coating is promising to meet the requirements for controlled release of nutrient and environmental protection.
基金Sponsored by the Departmet of Science ad Technology, Government of Heilongjiang Province(Grant No.GC04A407).
文摘The universal creep equation is successful in relating the creep （ε） to the aging time （t） , coefficient of retardation time （β） , and intrinsic time （ to ）. This relation was used to treat the creep experimental data for polyvinyl chloride （ PVC ） specimens at a given stress and different aging times. The βgs found by the “polynomial fitting” method in this work instead of the “middle - point” method reported in the literature. The unified master line was constructed with the treated data and curves according to the universal equation. The master line can be used to predict the long- term creed behavior and lifetime by extrapolating.
