The effects of 5 lactic acid bacteria(LAB)fermentation on the pasting properties of glutinous rice flour were compared,and suitable fermentation strains were selected based on the changes of viscosity,setback value,an...The effects of 5 lactic acid bacteria(LAB)fermentation on the pasting properties of glutinous rice flour were compared,and suitable fermentation strains were selected based on the changes of viscosity,setback value,and breakdown value to prepare LAB compound starter cultures.The results revealed that Latilactobacillus sakei HSD004 and Lacticaseibacillus rhamnosus HSD005 had apparent advantages in increasing the viscosity and reducing the setback and breakdown values of glutinous rice flour.In particular,the compound starter created using the two abovementioned LAB in the ratio of 3:1 had better performance than that using a single LAB in improving the pasting properties and increasing the water and oil absorption capacity of glutinous rice flour.Moreover,the gelatinization enthalpy of the fermented samples increased significantly.For frozen glutinous rice dough stored for 28 days,the viscoelasticity of frozen dough prepared by compound starter was better than that of control dough,and the freezable water content was lower than that of control dough.These results indicate that compound LAB fermentation is a promising technology in the glutinous rice-based food processing industry,which has significance for its application.展开更多
High-quality rice flour is the foundation for the production of various rice-based products.Milling is an essential step in obtaining rice flour,during which significant changes occur in the physicochemical and qualit...High-quality rice flour is the foundation for the production of various rice-based products.Milling is an essential step in obtaining rice flour,during which significant changes occur in the physicochemical and quality characteristics of the flour.Although rice flour obtained through mainstream wet milling methods exhibits superior quality,low production efficiency and wastewater discharge limit the development of the industry.Dry milling,on the other hand,conserves water resources,but adversely affects flour performance due to excessive heat generation.As an emerging powder-making technique,semi-dry milling offers a promising solution by enhancing flour quality and reducing environmental impact.This is achieved by minimizing soaking time through hot air treatment while reducing mechanical energy consumption to reach saturated water absorption levels.However,continuous production remains a challenge.This comprehensive review summarizes the effects of various milling technologies on rice flour properties and product qualities.It also discusses key control indicators and technical considerations for rice flour processing equipment and processes.展开更多
The quality of infant flours used during the weaning age is of great importance in that it conditions the nutritional health of infants and young children. This study aimed to assess the nutritional and sanitary quali...The quality of infant flours used during the weaning age is of great importance in that it conditions the nutritional health of infants and young children. This study aimed to assess the nutritional and sanitary quality of infant flours produced in the city of Ouagadougou. This was a cross-sectional study including 11 out of 25 infant flour production units that gave their consent to partake in the study. In total, 25 infant flour samples have been collected from July to September 2021. The physicochemical and microbiological parameters were determined according to standard methods. The ANOVA analysis of variance showed significant differences between the means of the physico-chemical and the means of the microbiological parameters respectively. The results showed that 60% of proteins and 80% of lipid and total carbohydrate contents were below the authorised limits. The energy values were below the authorised limit in 88% of the cases. All instant infant flours had microbiological loads compliant with Burkinabè standards. As for infant flour to be cooked, 63.64% and 81.82% had satisfactory numbers of total coliforms and faecal coliforms respectively. Staphylococcus aureus and Escherichia coli were detected in these samples with 86.36% of infant formulae having results below the recommended limit. These results show that the infant flours produced in Ouagadougou were somehow of acceptable quality. However, there is a need to improve the formulae for macronutrient contents, energy values and sanitary quality to comply with the recommendations.展开更多
Infant malnutrition is a significant issue in Côte d’Ivoire, and this study aims to address it by formulating infant flours using local ingredients. Fermentation, germination, and malting methods were used to en...Infant malnutrition is a significant issue in Côte d’Ivoire, and this study aims to address it by formulating infant flours using local ingredients. Fermentation, germination, and malting methods were used to enhance the quality of six formulated flours, all based on Fonio and supplemented with Bambara groundnut, African locust bean fruit pulp, and cashew kernels. Results showed that Fonio had the highest carbohydrate content, while Bambara groundnut and Cashew kernels were rich in protein and lipid content. African locust bean fruit pulp was rich in fiber and Vitamin C, with a high β-carotene value. The cashew kernel had the highest energy value. Regarding mineral composition, African locust bean fruit pulp had the highest potassium content, while Bambara groundnut and African locust bean fruit pulp were rich in sodium. Cashew kernel and Fonio had higher iron and calcium content. Bambara groundnut had a higher zinc content, while cashew kernel had a higher magnesium content. The formulated flours made from fermented Fonio grains and enriched with Bambara groundnut, African locust bean fruit pulp, and cashew kernel had varying protein, fiber, carbohydrate, ash, and fat contents. The flour formulated with sprouted Fonio and enriched with the same ingredients had higher protein content and energy value than the other fermented seed-based flours. The mixed flours produced with fermented seeds and the flour produced from sprouted seeds met international standards. Overall, these findings offer valuable insights into the nutritional composition of the formulated flours and their potential to combat infant malnutrition in Côte d’Ivoire.展开更多
The aim of the present study was to investigate on the inventory and determination of the nutritional value of cereals flour and cassava leaves powder in order to analyse their use in the production of infant flour. I...The aim of the present study was to investigate on the inventory and determination of the nutritional value of cereals flour and cassava leaves powder in order to analyse their use in the production of infant flour. In this paper, a A survey to identify the cereals used in the preparation of infant porridge in the Northern Cameroon was done by using 447 mothers having children between 06 and 59 months from areas (Gbakoungue, Sassa-Mbersi, Sanguere-Ngal and Kotkong-Wouldata) with high rate on malnourished children. Flour was prepared from the most preponderant cereals and Cassava leaves powder from varieties identified by the Regional Centre of Agricultural Research (CRRA) of Wakwa and local population. Flour and powder samples obtained were subjected to chemical composition analysis. Parameters analysed were crude proteins, total carbohydrates, ash, total fats, total phenols, total tannins, total carotenoids, vitamin C or cyanide. Also Iron, calcium and zinc were determined. The results revealed that white maize (62%) was the main cereal used in the preparation of infant porridge followed respectively by red sorghum, white rice and muskwari. Ten cassava varieties were identified: three (03) by CRRA (TME, 96/1/14 and IRAD 4115) and seven (south, gambada, sweet, Benin, six months, M. glaziovii and grouna) by local population. Amongst cereals flour, those from white maize indicated high protein (10.09%), carbohydrates (84.46%) and total fat (7.46%) contents. The powder from 96/14/14 cassava variety showed high amount of iron (11.98 mg/100g), calcium (751.02 g/100g) and low cyanide content (1.21 ppm) amongst all the cassava leaves powder samples. The supplementation of white maize flour by cassava leaves powder from 96/14/14 variety could therefore be recommended for the preparation of infant flours.展开更多
This study makes it possible to establish baking flours of nutritional quality and technologically acceptable following the increase in their rheological parameters due to the insertion of gluten flour. The composite ...This study makes it possible to establish baking flours of nutritional quality and technologically acceptable following the increase in their rheological parameters due to the insertion of gluten flour. The composite flours were obtained using the Philips mixer type (model HR2811). The nutritional qualities of the formulated flours were determined by the Kjeldahl, AOAC 985-29, UV-VIS spectrophotometry (DR 5000;HACH and LANGE, France) and Soxhlet gravimetric methods. The compounds obtained are respectively: Protein, carbohydrate, lipid, micronutrient and vitamin contents. Monitoring the analysis of functional properties (water and oil absorption capacity) as well as baking value.展开更多
The inclusion of composite flours in infant food at weaning time should be a priority for mothers. The aim of this project is to formulate infant flour based on pulp flour enriched with oilcake from these grains after...The inclusion of composite flours in infant food at weaning time should be a priority for mothers. The aim of this project is to formulate infant flour based on pulp flour enriched with oilcake from these grains after extraction of the oil. To do this, the elements were combined to obtain a regulatory formulation. Micro- and macronutrients, minerals, vitamins and tasting of the prepared porridge were determined. The results obtained were satisfactory. The moisture content of the fruit pulp was determined using oven-drying techniques: 92.2%, carbohydrates 6.00%, lipids 0.3%, ash 0.80%, proteins 1.10%, calcium 19.8%, phosphorus 42.6% and iron 0.4%. Furthermore, the carbohydrate content of flours composed of 5% insertion is 62.9 g to 48.8 g per 100 g, and the protein content of compound flours with 5% insertion is 15.9 g to 28.25 g per 100 g. On the other hand, the vitamin C and E contents of fresh pulp and oilcake are 25 mg, 13 mg and 21 mg respectively. However, only copper and β-carotene from 5% to 30% insertion remain invariant to the different insertion rates, with a value of 25 mg for copper and 0 µg for β-carotene. In addition, a variation in the degree of swelling of weaning flours compared with the standard from 3.95% at 5% insertion to 3.58 at 30% insertion was observed. The solubility of flours increases on the one hand with increases in the degree of insertion of the cakes. Flour formulated so many toward basicity. But the presence of traces of oil containing fatty acids can reduce this basicity. This study may be an alternative of industrial flours in infant nutrition.展开更多
The mechanism of glutinous rice flour,a kind of natural admixture,on the hydration process,setting time,and microstructure of the Portland cement was investigated.The experimental results show that the glutinous rice ...The mechanism of glutinous rice flour,a kind of natural admixture,on the hydration process,setting time,and microstructure of the Portland cement was investigated.The experimental results show that the glutinous rice flour has an obvious setting retarding effect on cement pastes.The optimal dosage of the glutinous rice flour is 3wt%.In this case,the initial and final setting time of the paste are delayed by 140 and185 min,respectively.The flexural and compressive strengths of the hardened paste are increased by 0.35%and 0.07%after 56 d of curing.The glutinous rice flour hinders the mineral dissolution process and decreases the concentration of calcium ion at the initial stage of hydration due to the complexation effect,thereby hindering the nucleation and growth of CH and C-S-H phases and prolonging the hydration process.However,C-S-H phases combine with the glutinous rice flour to contribute the bonding effect together,which compacts the microstructure of hardened cement pastes at the later hydration stage of cement pastes.Thus,in-depth investigation on the utilization of glutinous rice flour as the admixture for the Portland cement is expected to be meaningful for the control of hydration exothermic rate and setting time.展开更多
The present investigation was aimed to study functional properties,antioxidant activity and in-vitro digestibility characteristics of brown and polished flours obtained from four rice cultivars(SR-4,K-39,Mushq Budij a...The present investigation was aimed to study functional properties,antioxidant activity and in-vitro digestibility characteristics of brown and polished flours obtained from four rice cultivars(SR-4,K-39,Mushq Budij and Zhag)of Kashmir.Brown rice flours had higher total dietary fibre(3.08%-3.68%),oil absorption(116.0%-139.0%),emulsion capacity(4.78%-9.52%),emulsion stability(87.46%-99.93%)and resistant starch content(6.80%-9.00%)than polished flours.However,polished flours presented greater water absorption(102.0%-122.0%),foaming capacity(8.00%-13.63%),apparent amylose(19.16%-22.62%),peak(2260.0-2408.0 cP),trough(1372.0-1589.0 cP)and breakdown(714.0-978.0 cP)viscosities than their brown counterparts.Brown rice flours depicted highest total phenolic content(4.40-6.40 mg GAE/g)and inhibition of lipid peroxidation(19.50%-33.20%).However,equilibrium starch hydrolysis percentage(C∞)and predicted glycemic index of brown rice flours were lower than their polished counterparts.Among rice cultivars,brown Zhag flour had the highest total dietary fibre(3.68%),emulsion capacity(9.52%),emulsion stability(99.93%),resistant starch(9.00%),DPPH radical scavenging activity(85.45%)and inhibition of lipid peroxidation(33.20%),respectively.Emulsion capacity and emulsion stability were positively correlated with protein content of rice flours.However,peak,trough,breakdown and setback viscosities were negatively correlated with protein and fat contents of rice flour.The present investigation will be helpful in identifying nutritive role of rice flours from studied cultivars in human diet.展开更多
Aflatoxins are toxic metabolites present in various foods, especially when production and conservation do not respect good hygiene practices (GHP). In Ouagadougou, maize flour is produced and sold in different structu...Aflatoxins are toxic metabolites present in various foods, especially when production and conservation do not respect good hygiene practices (GHP). In Ouagadougou, maize flour is produced and sold in different structures by actors who do not always respect GHP. Thus, it is necessary to regularly control the quality of these flours. So, this is carried out with the aim to assess the aflatoxin content of maize flours produced in the municipality of Ouagadougou. For this, twenty-eight (28) samples were collected from households, markets and supermarkets in the city of Ouagadougou. Thus, LC/MS/MS analysis was used to assess the aflatoxin content of the samples. The results obtained reveal the presence of total aflatoxins (AFT) in 78.57% of samples analyzed with levels ranging from 0.89 to 64.25 μg/kg. The prevalence of different types of aflatoxins were 57.14% for aflatoxin B1 (AFB1), 46.43% for aflatoxin B2 (AFB2), 42.86% for aflatoxin G1 (AFG1) and 4.6% for aflatoxin G2 (AFG2). The results also show that 80% and 60% of market samples, 70% and 30% of household samples and 37.5% and 25% of supermarket samples do not comply with European Commission standards for AFT and AFB1 respectively. For all the samples, 60.71% and 42.86% of the samples are compliant according to the limits established by the European Commission (EC) respectively for AFB1 and AFT. Regarding the results obtained, producers and processors must be supervised and trained in GHP for the production of better-quality flours.展开更多
This study assesses the nutritional composition as well as the availability and affordability of infant flour found on the market and in the households of Benin. To do that assessment, a two-step cross-sectional surve...This study assesses the nutritional composition as well as the availability and affordability of infant flour found on the market and in the households of Benin. To do that assessment, a two-step cross-sectional survey based on food ethnography methods was used. A total of 61 marketplaces were visited in seven towns and rural districts as part of the availability and affordability survey, while 400 children (aged 6 to 59 months) were surveyed to track the uses of infant flours at the household level. The results obtained reveal that pre-manufactured infant flour is sold more in urban areas (Cotonou, Porto-Novo and Parakou) than in rural ones. The average infant flours price did not vary (p = 0.985) in any given year (regardless of abundance or lean periods) nor does it vary (p = 0.133) from one point of sale to another (drugstore or supermarkets). However, the average price is found to be expensive considering the purchasing power of the households surveyed. On the other hand, the amount of ingredients used in the production of the flour types found on the market complies with the recommendations of the Codex Alimentarius, unlike the homemade ones. Pre-manufactured infant flour is found to be outside of the economic reach of most households (92%) who rely heavily on the homemade ones to feed their children. In light of the above, public authorities should help improve geographic access and pricing affordability to quality infant flour for low-income households in urban and remote areas. Moreover, awareness should be raised among mothers relative to the importance of complementary feeding through education on good nutrition practices.展开更多
Occupational exposure to flour dust within bakery environments presents significant health hazards to bakery personnel.Flour dust,generated as a byproduct during baking,becomes airborne during the baking process,thus ...Occupational exposure to flour dust within bakery environments presents significant health hazards to bakery personnel.Flour dust,generated as a byproduct during baking,becomes airborne during the baking process,thus constituting a respiratory threat.Adverse health consequences include respiratory diseases,skin irritation,allergic reactions,and potential long-term health impacts.Data indicates that a broad segment of bakery workers encounters exposure to flour dust,with specific subgroups,such as bakers and dough mixers,being particularly susceptible.Contributing factors to this exposure encompass insufficient ventilation and a lack of awareness.It is vital to assess exposure levels through air quality monitoring and health surveillance.Efficient interventions encompass engineering solutions(e.g.,ventilation systems,dust extraction),administrative measures(including training and the use of personal protective equipment),and the implementation of occupational health and safety programs.Collaborative efforts with healthcare professionals and regulatory authorities are paramount for achieving success.Case studies underscore the effectiveness of such interventions,resulting in improved worker health,thus underscoring the advantages of protective measures.Challenges in this endeavor include industry resistance to change,financial considerations,and issues related to compliance.Future recommendations entail further research,policy enhancements,and the involvement of industry stakeholders and labor unions in advocating for worker safety.展开更多
为设计和优化面粉输送设备,应用离散元法对面粉进行准确地工程建模和分析,需要对其接触参数进行必要的标定。该研究依据颗粒缩放理论,用“Hertz-Mindlin with Johnson-Kendall-Roberts”接触模型表征面粉颗粒间黏性的影响,提出了一种基...为设计和优化面粉输送设备,应用离散元法对面粉进行准确地工程建模和分析,需要对其接触参数进行必要的标定。该研究依据颗粒缩放理论,用“Hertz-Mindlin with Johnson-Kendall-Roberts”接触模型表征面粉颗粒间黏性的影响,提出了一种基于静/动态休止角的接触参数标定方法。运用正交试验方法,对接触参数的敏感性和方差分析,表明面粉颗粒间的滚动摩擦系数、面粉颗粒与不锈钢表面间的静摩擦系数、表面能对静态休止角的影响极显著(P<0.01),并且多组接触参数都可以模拟出与试验相同的静态休止角。进一步研究表明,面粉颗粒与不锈钢表面间的静摩擦系数的合理取值范围为0.2~0.4。通过2种填充率、4种转速下基于动态休止角的参数标定,将其中与试验最为吻合的一组参数作为标定结果,其值如下:面粉颗粒之间恢复系数为0.6、面粉颗粒之间静摩擦系数为0.2、面粉颗粒之间滚动摩擦系数为0.1、面粉颗粒与不锈钢容器表面之间恢复系数为0.6、面粉颗粒与不锈钢容器表面之间静摩擦系数为0.6、面粉颗粒与不锈钢容器表面之间滚动摩擦系数为0.5、表面能为0.12 J/m^(2)。使用该组参数对矩形容器中物料自由坍塌试验进行仿真,其结果与试验结果相符,验证了该标定方法的有效性。该研究提出的标定方法简单、易执行,对粉料输送设备的设计及优化具有一定的工程应用价值。展开更多
基金supported by the National Key Research and Development Program of China(2021YFD2100902-3)the National Natural Science Foundation of China(32072258)+5 种基金Major Science and Technology Program of Heilongjiang(2020ZX08B02)Harbin University of Commerce“Young Innovative Talents”Support Program(2019CX062020CX262020CX27)the Central Financial Support for the Development of Local Colleges and Universities,Graduate Innovation Research Project of Harbin University of Commerce(YJSCX2021-698HSD)Training plan of Young Innovative Talents in Universities of Heilongjiang(UNPYSCT-2020218).
文摘The effects of 5 lactic acid bacteria(LAB)fermentation on the pasting properties of glutinous rice flour were compared,and suitable fermentation strains were selected based on the changes of viscosity,setback value,and breakdown value to prepare LAB compound starter cultures.The results revealed that Latilactobacillus sakei HSD004 and Lacticaseibacillus rhamnosus HSD005 had apparent advantages in increasing the viscosity and reducing the setback and breakdown values of glutinous rice flour.In particular,the compound starter created using the two abovementioned LAB in the ratio of 3:1 had better performance than that using a single LAB in improving the pasting properties and increasing the water and oil absorption capacity of glutinous rice flour.Moreover,the gelatinization enthalpy of the fermented samples increased significantly.For frozen glutinous rice dough stored for 28 days,the viscoelasticity of frozen dough prepared by compound starter was better than that of control dough,and the freezable water content was lower than that of control dough.These results indicate that compound LAB fermentation is a promising technology in the glutinous rice-based food processing industry,which has significance for its application.
基金supported by the National Natural Science Foundation of China(Grant No.31972005)Xinjiang Uygur Autonomous Region‘Tianshan Talent’Training Plan Project,China(Grant No.2022TSYCCX0063).
文摘High-quality rice flour is the foundation for the production of various rice-based products.Milling is an essential step in obtaining rice flour,during which significant changes occur in the physicochemical and quality characteristics of the flour.Although rice flour obtained through mainstream wet milling methods exhibits superior quality,low production efficiency and wastewater discharge limit the development of the industry.Dry milling,on the other hand,conserves water resources,but adversely affects flour performance due to excessive heat generation.As an emerging powder-making technique,semi-dry milling offers a promising solution by enhancing flour quality and reducing environmental impact.This is achieved by minimizing soaking time through hot air treatment while reducing mechanical energy consumption to reach saturated water absorption levels.However,continuous production remains a challenge.This comprehensive review summarizes the effects of various milling technologies on rice flour properties and product qualities.It also discusses key control indicators and technical considerations for rice flour processing equipment and processes.
文摘The quality of infant flours used during the weaning age is of great importance in that it conditions the nutritional health of infants and young children. This study aimed to assess the nutritional and sanitary quality of infant flours produced in the city of Ouagadougou. This was a cross-sectional study including 11 out of 25 infant flour production units that gave their consent to partake in the study. In total, 25 infant flour samples have been collected from July to September 2021. The physicochemical and microbiological parameters were determined according to standard methods. The ANOVA analysis of variance showed significant differences between the means of the physico-chemical and the means of the microbiological parameters respectively. The results showed that 60% of proteins and 80% of lipid and total carbohydrate contents were below the authorised limits. The energy values were below the authorised limit in 88% of the cases. All instant infant flours had microbiological loads compliant with Burkinabè standards. As for infant flour to be cooked, 63.64% and 81.82% had satisfactory numbers of total coliforms and faecal coliforms respectively. Staphylococcus aureus and Escherichia coli were detected in these samples with 86.36% of infant formulae having results below the recommended limit. These results show that the infant flours produced in Ouagadougou were somehow of acceptable quality. However, there is a need to improve the formulae for macronutrient contents, energy values and sanitary quality to comply with the recommendations.
文摘Infant malnutrition is a significant issue in Côte d’Ivoire, and this study aims to address it by formulating infant flours using local ingredients. Fermentation, germination, and malting methods were used to enhance the quality of six formulated flours, all based on Fonio and supplemented with Bambara groundnut, African locust bean fruit pulp, and cashew kernels. Results showed that Fonio had the highest carbohydrate content, while Bambara groundnut and Cashew kernels were rich in protein and lipid content. African locust bean fruit pulp was rich in fiber and Vitamin C, with a high β-carotene value. The cashew kernel had the highest energy value. Regarding mineral composition, African locust bean fruit pulp had the highest potassium content, while Bambara groundnut and African locust bean fruit pulp were rich in sodium. Cashew kernel and Fonio had higher iron and calcium content. Bambara groundnut had a higher zinc content, while cashew kernel had a higher magnesium content. The formulated flours made from fermented Fonio grains and enriched with Bambara groundnut, African locust bean fruit pulp, and cashew kernel had varying protein, fiber, carbohydrate, ash, and fat contents. The flour formulated with sprouted Fonio and enriched with the same ingredients had higher protein content and energy value than the other fermented seed-based flours. The mixed flours produced with fermented seeds and the flour produced from sprouted seeds met international standards. Overall, these findings offer valuable insights into the nutritional composition of the formulated flours and their potential to combat infant malnutrition in Côte d’Ivoire.
文摘The aim of the present study was to investigate on the inventory and determination of the nutritional value of cereals flour and cassava leaves powder in order to analyse their use in the production of infant flour. In this paper, a A survey to identify the cereals used in the preparation of infant porridge in the Northern Cameroon was done by using 447 mothers having children between 06 and 59 months from areas (Gbakoungue, Sassa-Mbersi, Sanguere-Ngal and Kotkong-Wouldata) with high rate on malnourished children. Flour was prepared from the most preponderant cereals and Cassava leaves powder from varieties identified by the Regional Centre of Agricultural Research (CRRA) of Wakwa and local population. Flour and powder samples obtained were subjected to chemical composition analysis. Parameters analysed were crude proteins, total carbohydrates, ash, total fats, total phenols, total tannins, total carotenoids, vitamin C or cyanide. Also Iron, calcium and zinc were determined. The results revealed that white maize (62%) was the main cereal used in the preparation of infant porridge followed respectively by red sorghum, white rice and muskwari. Ten cassava varieties were identified: three (03) by CRRA (TME, 96/1/14 and IRAD 4115) and seven (south, gambada, sweet, Benin, six months, M. glaziovii and grouna) by local population. Amongst cereals flour, those from white maize indicated high protein (10.09%), carbohydrates (84.46%) and total fat (7.46%) contents. The powder from 96/14/14 cassava variety showed high amount of iron (11.98 mg/100g), calcium (751.02 g/100g) and low cyanide content (1.21 ppm) amongst all the cassava leaves powder samples. The supplementation of white maize flour by cassava leaves powder from 96/14/14 variety could therefore be recommended for the preparation of infant flours.
文摘This study makes it possible to establish baking flours of nutritional quality and technologically acceptable following the increase in their rheological parameters due to the insertion of gluten flour. The composite flours were obtained using the Philips mixer type (model HR2811). The nutritional qualities of the formulated flours were determined by the Kjeldahl, AOAC 985-29, UV-VIS spectrophotometry (DR 5000;HACH and LANGE, France) and Soxhlet gravimetric methods. The compounds obtained are respectively: Protein, carbohydrate, lipid, micronutrient and vitamin contents. Monitoring the analysis of functional properties (water and oil absorption capacity) as well as baking value.
文摘The inclusion of composite flours in infant food at weaning time should be a priority for mothers. The aim of this project is to formulate infant flour based on pulp flour enriched with oilcake from these grains after extraction of the oil. To do this, the elements were combined to obtain a regulatory formulation. Micro- and macronutrients, minerals, vitamins and tasting of the prepared porridge were determined. The results obtained were satisfactory. The moisture content of the fruit pulp was determined using oven-drying techniques: 92.2%, carbohydrates 6.00%, lipids 0.3%, ash 0.80%, proteins 1.10%, calcium 19.8%, phosphorus 42.6% and iron 0.4%. Furthermore, the carbohydrate content of flours composed of 5% insertion is 62.9 g to 48.8 g per 100 g, and the protein content of compound flours with 5% insertion is 15.9 g to 28.25 g per 100 g. On the other hand, the vitamin C and E contents of fresh pulp and oilcake are 25 mg, 13 mg and 21 mg respectively. However, only copper and β-carotene from 5% to 30% insertion remain invariant to the different insertion rates, with a value of 25 mg for copper and 0 µg for β-carotene. In addition, a variation in the degree of swelling of weaning flours compared with the standard from 3.95% at 5% insertion to 3.58 at 30% insertion was observed. The solubility of flours increases on the one hand with increases in the degree of insertion of the cakes. Flour formulated so many toward basicity. But the presence of traces of oil containing fatty acids can reduce this basicity. This study may be an alternative of industrial flours in infant nutrition.
基金Funded by the Open Fund of Key Laboratory for Advanced Technology in Environmental Protection of Jiangsu Province (JBGS008)the Research Lab Construction of Hainan University (ZY2019HN0904)the Opening Project of State Key Laboratory of Green Building Materials (2022GBM01)。
文摘The mechanism of glutinous rice flour,a kind of natural admixture,on the hydration process,setting time,and microstructure of the Portland cement was investigated.The experimental results show that the glutinous rice flour has an obvious setting retarding effect on cement pastes.The optimal dosage of the glutinous rice flour is 3wt%.In this case,the initial and final setting time of the paste are delayed by 140 and185 min,respectively.The flexural and compressive strengths of the hardened paste are increased by 0.35%and 0.07%after 56 d of curing.The glutinous rice flour hinders the mineral dissolution process and decreases the concentration of calcium ion at the initial stage of hydration due to the complexation effect,thereby hindering the nucleation and growth of CH and C-S-H phases and prolonging the hydration process.However,C-S-H phases combine with the glutinous rice flour to contribute the bonding effect together,which compacts the microstructure of hardened cement pastes at the later hydration stage of cement pastes.Thus,in-depth investigation on the utilization of glutinous rice flour as the admixture for the Portland cement is expected to be meaningful for the control of hydration exothermic rate and setting time.
基金The authors are thankful to Rice Research Centres of Anantnag and Kupwara,J&K for helping us in getting paddy.
文摘The present investigation was aimed to study functional properties,antioxidant activity and in-vitro digestibility characteristics of brown and polished flours obtained from four rice cultivars(SR-4,K-39,Mushq Budij and Zhag)of Kashmir.Brown rice flours had higher total dietary fibre(3.08%-3.68%),oil absorption(116.0%-139.0%),emulsion capacity(4.78%-9.52%),emulsion stability(87.46%-99.93%)and resistant starch content(6.80%-9.00%)than polished flours.However,polished flours presented greater water absorption(102.0%-122.0%),foaming capacity(8.00%-13.63%),apparent amylose(19.16%-22.62%),peak(2260.0-2408.0 cP),trough(1372.0-1589.0 cP)and breakdown(714.0-978.0 cP)viscosities than their brown counterparts.Brown rice flours depicted highest total phenolic content(4.40-6.40 mg GAE/g)and inhibition of lipid peroxidation(19.50%-33.20%).However,equilibrium starch hydrolysis percentage(C∞)and predicted glycemic index of brown rice flours were lower than their polished counterparts.Among rice cultivars,brown Zhag flour had the highest total dietary fibre(3.68%),emulsion capacity(9.52%),emulsion stability(99.93%),resistant starch(9.00%),DPPH radical scavenging activity(85.45%)and inhibition of lipid peroxidation(33.20%),respectively.Emulsion capacity and emulsion stability were positively correlated with protein content of rice flours.However,peak,trough,breakdown and setback viscosities were negatively correlated with protein and fat contents of rice flour.The present investigation will be helpful in identifying nutritive role of rice flours from studied cultivars in human diet.
文摘Aflatoxins are toxic metabolites present in various foods, especially when production and conservation do not respect good hygiene practices (GHP). In Ouagadougou, maize flour is produced and sold in different structures by actors who do not always respect GHP. Thus, it is necessary to regularly control the quality of these flours. So, this is carried out with the aim to assess the aflatoxin content of maize flours produced in the municipality of Ouagadougou. For this, twenty-eight (28) samples were collected from households, markets and supermarkets in the city of Ouagadougou. Thus, LC/MS/MS analysis was used to assess the aflatoxin content of the samples. The results obtained reveal the presence of total aflatoxins (AFT) in 78.57% of samples analyzed with levels ranging from 0.89 to 64.25 μg/kg. The prevalence of different types of aflatoxins were 57.14% for aflatoxin B1 (AFB1), 46.43% for aflatoxin B2 (AFB2), 42.86% for aflatoxin G1 (AFG1) and 4.6% for aflatoxin G2 (AFG2). The results also show that 80% and 60% of market samples, 70% and 30% of household samples and 37.5% and 25% of supermarket samples do not comply with European Commission standards for AFT and AFB1 respectively. For all the samples, 60.71% and 42.86% of the samples are compliant according to the limits established by the European Commission (EC) respectively for AFB1 and AFT. Regarding the results obtained, producers and processors must be supervised and trained in GHP for the production of better-quality flours.
文摘This study assesses the nutritional composition as well as the availability and affordability of infant flour found on the market and in the households of Benin. To do that assessment, a two-step cross-sectional survey based on food ethnography methods was used. A total of 61 marketplaces were visited in seven towns and rural districts as part of the availability and affordability survey, while 400 children (aged 6 to 59 months) were surveyed to track the uses of infant flours at the household level. The results obtained reveal that pre-manufactured infant flour is sold more in urban areas (Cotonou, Porto-Novo and Parakou) than in rural ones. The average infant flours price did not vary (p = 0.985) in any given year (regardless of abundance or lean periods) nor does it vary (p = 0.133) from one point of sale to another (drugstore or supermarkets). However, the average price is found to be expensive considering the purchasing power of the households surveyed. On the other hand, the amount of ingredients used in the production of the flour types found on the market complies with the recommendations of the Codex Alimentarius, unlike the homemade ones. Pre-manufactured infant flour is found to be outside of the economic reach of most households (92%) who rely heavily on the homemade ones to feed their children. In light of the above, public authorities should help improve geographic access and pricing affordability to quality infant flour for low-income households in urban and remote areas. Moreover, awareness should be raised among mothers relative to the importance of complementary feeding through education on good nutrition practices.
文摘Occupational exposure to flour dust within bakery environments presents significant health hazards to bakery personnel.Flour dust,generated as a byproduct during baking,becomes airborne during the baking process,thus constituting a respiratory threat.Adverse health consequences include respiratory diseases,skin irritation,allergic reactions,and potential long-term health impacts.Data indicates that a broad segment of bakery workers encounters exposure to flour dust,with specific subgroups,such as bakers and dough mixers,being particularly susceptible.Contributing factors to this exposure encompass insufficient ventilation and a lack of awareness.It is vital to assess exposure levels through air quality monitoring and health surveillance.Efficient interventions encompass engineering solutions(e.g.,ventilation systems,dust extraction),administrative measures(including training and the use of personal protective equipment),and the implementation of occupational health and safety programs.Collaborative efforts with healthcare professionals and regulatory authorities are paramount for achieving success.Case studies underscore the effectiveness of such interventions,resulting in improved worker health,thus underscoring the advantages of protective measures.Challenges in this endeavor include industry resistance to change,financial considerations,and issues related to compliance.Future recommendations entail further research,policy enhancements,and the involvement of industry stakeholders and labor unions in advocating for worker safety.
文摘为设计和优化面粉输送设备,应用离散元法对面粉进行准确地工程建模和分析,需要对其接触参数进行必要的标定。该研究依据颗粒缩放理论,用“Hertz-Mindlin with Johnson-Kendall-Roberts”接触模型表征面粉颗粒间黏性的影响,提出了一种基于静/动态休止角的接触参数标定方法。运用正交试验方法,对接触参数的敏感性和方差分析,表明面粉颗粒间的滚动摩擦系数、面粉颗粒与不锈钢表面间的静摩擦系数、表面能对静态休止角的影响极显著(P<0.01),并且多组接触参数都可以模拟出与试验相同的静态休止角。进一步研究表明,面粉颗粒与不锈钢表面间的静摩擦系数的合理取值范围为0.2~0.4。通过2种填充率、4种转速下基于动态休止角的参数标定,将其中与试验最为吻合的一组参数作为标定结果,其值如下:面粉颗粒之间恢复系数为0.6、面粉颗粒之间静摩擦系数为0.2、面粉颗粒之间滚动摩擦系数为0.1、面粉颗粒与不锈钢容器表面之间恢复系数为0.6、面粉颗粒与不锈钢容器表面之间静摩擦系数为0.6、面粉颗粒与不锈钢容器表面之间滚动摩擦系数为0.5、表面能为0.12 J/m^(2)。使用该组参数对矩形容器中物料自由坍塌试验进行仿真,其结果与试验结果相符,验证了该标定方法的有效性。该研究提出的标定方法简单、易执行,对粉料输送设备的设计及优化具有一定的工程应用价值。
